直升机旋翼轴弯矩特征及应用

doi:10.7527/S1000-6893.2020.24168

Abstract

Abstract: The rotor shaft bending moments are produced by mΩ dynamic flapping forces, unbalanced components of static flapping forces, dynamic drag forces, dynamic centrifugation forces and unbalanced components of static centrifugation forces of the arms on spheriflex hub helicopters. The amplitude, frequency, phase position and distribution laws of rotor shaft bending moments are analyzed in this paper. After the flight load measurement for a helicopter is performed, the characteristics of the measured rotor shaft bending moments are analyzed, establishing the effectiveness criteria, distinguishing the non-effective data, and finally compiling the measured fatigue load spectrums. The analysis of the helicopter shows that in the rotor coordinate system, the dynamic moments are much larger than the static moments while the unbalanced static flapping force and static centrifugation force are small. The main components of rotor shaft bending moments are 1Ω moments produced by the 1Ω flapping force, the drag force and the centrifugation force. The combined bending moments exhibit the same amplitude in one section rotating around the rotor shaft, the similar amplitude and the same phase difference with the different circumferential position along the shaft.

Key words: helicopters, rotor shaft bending moments, characteristics, fatigue, load spectrums

CLC Number:

V215.1

CHEN Yaping, YU Jianjian, HU Lei, WANG Yutang. Characteristics and application of bending moments of helicopter rotor shaft[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2021, 42(5): 524168-524168.

References 20

[1]	习娟,吴裕平,陈平剑. 直升机旋翼系统载荷分析技术[J]. 直升机技术,2007,3:52-54. XI J, WU Y P, CHEN P J. The loads analysis technology of the helicopter rotor system[J]. Helicopter Technique, 2007,3:52-54(in Chinese).
[2]	寇富军. 直升机桨毂力、力矩试飞研究[C]//第十八届(2002)全国直升机年会论文集. 北京:中国航空学会, 2002:426-430. KOU F J. Research on load and moment of helicopter hub in flight test[C]//Proceedings of National Helicopter Conference. Beijing:Chinese Society of Aeronautics and Astronautics, 2002:426-430(in Chinese).
[3]	习娟,吴裕平,陈平剑. 直升机旋翼载荷飞行测试结果的分析与应用[J]. 南京航空航天大学学报,2011,43(3):419-422. XI J, WU Y P, CHEN P J. Analysis and application of flight test results for helicopter rotor systems loads[J]. Journal of Nanjing university of aeronautics & astronautics, 2011,43(3):419-422(in Chinese).
[4]	刘福华,刘丙坤. 直升机尾桨动部件载荷测试技术方法研究与应用[J]. 测控技术,2007,26(1):84-86. LIU F H, LIU B K. Research and application of flight testing technology in loads test of helicopter's tail rotating components[J]. Measurement & Control Technology, 2007,26(1):84-86(in Chinese).
[5]	李永寿,唐丽芳. 直升机飞行状态下传动系统载荷测试研究[J]. 科技创新导报,2011,6:2-3. LI Y S, TANG L F. Research on loads measuring of drive system in flight for helicopter[J]. Science and Technology Innovation Herald, 2011,6:2-3(in Chinese).
[6]	卢京明,孙详. 飞行主操纵系统疲劳试验载荷监控方法研究——应变数据分析法[J]. 飞机设计,2006,2:21-31. LU J M, SUN X. A fatigue loading monitoring method based on strain data analysis in primary flight control system fatigue tests[J]. Measurement & Control Technology, 2006,2:21-31(in Chinese).
[7]	吴志刚,秦强. 影响旋翼轴载荷测试精度的因素分析[J]. 测控技术,2011,30:285-287. WU Z G, QIN Q. Analysis of factors that affect the test accuracy of helicopter's main rotor shaft load[J]. Measurement & Control Technology, 2011,30:285-287(in Chinese).
[8]	段垚奇,刘克格,赵丽娜,等. 飞机载荷标定试验数据的多元回归选元方法[J]. 振动、测试与诊断,2015,1:178-182. DUAN Y Q, LIU K G, ZHAO L N, et al. Regression selection based on multiple regression analysis for calibration test data of airplane loads[J]. Journal of Vibration, Measurement & Diagnosis, 2015,1:178-182(in Chinese).
[9]	章海红,寇富军. 直11旋翼轴载荷测试研究[J]. 直升机技术,2012,1:25-28. ZHANG H H, KOU F J. Testing rotor shaft load for a Z11 helicopter[J]. Helicopter Technique, 2012,1:25-28(in Chinese).
[10]	张新民,郑甲宏. 直升机液压阻尼器应力载荷试飞研究[C]//第二十九届(2013)全国直升机年会论文集. 北京:中国航空学会, 2013:235-238. ZHANG X M, ZHENG J H. Research on stress load of hydraulic damper in flight test[C]//Proceedings of National Helicopter Conference. Beijing:Chinese Society of Aeronautics and Astronautics, 2013:235-238(in Chinese).
[11]	张永峰,张强,任瑞冬. 螺旋桨1P载荷飞行试验桨轴测试研究[J]. 飞行力学,2011,29(6):84-87. ZHANG Y F, ZHANG Q, REN R D. Measuring research of propeller 1P loads at power shaft in flight test[J]. Flight Dynamics, 2011,29(6):84-87(in Chinese).
[12]	潘春蛟,喻溅鉴,巴唐尧,等. 直升机飞行载荷应用探讨[J]. 直升机技术,2012,4:17-21. PAN C J, YU J J, BA T Y, et al. Behavior discussion on flight loads of helicopter structure[J]. Helicopter Technique, 2012,4:17-21(in Chinese).
[13]	顾文标,喻溅鉴,潘春蛟,等. 直升机飞行实测载荷有效性分析技术[J]. 直升机技术,2007,4:19-23. GU W B, YU J J, PAN C J, et al. Validity analysis technology of flight test load for helicopter[J]. Helicopter Technique, 2007,4:19-23(in Chinese).
[14]	林军. 直九H425型机传动系统载荷谱测绘研究[D]. 哈尔滨:哈尔滨工程大学, 2006:53-61. LIN J. The study about load measuring of the H425 helicopter transmission system[D]. Harbin:Harbin Engineering University, 2006:53-61(in Chinese).
[15]	张功虎,顾文标,喻溅鉴,等. 基于飞行载荷分析的直升机动部件故障识别研究[J]. 直升机技术,2011,1:1-5. ZHANG G H, GU W B, YU J J, et al. Failure identify study on helicopter rotating part based on flight load character analysis[J]. Helicopter Technique, 2011,1:1-5(in Chinese).
[16]	柳文林,穆志韬,金平. 直升机飞行动作时间比例改变对动部件疲劳损伤影响分析[J]. 机械强度,2008,30(5):789-793. LIU W L, MU Z T, JIN P. Influence of flight time proportion on fatigue damage for helicopter dynamic components[J]. Journal of Strength, 2008,30(5):789-793(in Chinese).
[17]	穆志韬,段成美,华燃. 直升机某动部件飞行状态的载荷分布特点研究[J]. 南京航空航天大学学报,2001,33(5):503-506. MU Z T, DUAN C M, HUA R. Load features of flight conditions on dynamic component of helicopter[J]. Journal of Nanjing University of Aeronautics & Astronautics, 2001,33(5):503-506(in Chinese).
[18]	MARK V, WALKER D J, MANIMALA B, et al. First steps towards the design of an active pitch link loads reduction system using novel control techniques[C]//The 31 st European Rotorcraft Forum,2005.
[19]	王建,秦瑞芬,吴艳霞. 基于飞行测量的弹性轴承试验载荷谱修正和寿命评估方法[J]. 直升机技术,2013,1:1-9. WANG J, QIN R F, WU Y X. Spherical thrust bearing load spectra adjust based on flight test and service life evaluation[J]. Helicopter Technique, 2013,1:1-9(in Chinese).
[20]	康宁,闫晓军,李晓甫,等. 高低周复合疲劳试验中振动应力的监测与计算[J]. 燃气涡轮试验与研究,2010,4:22-25. KANG N, YAN X J, LI X F, et al. Numerical calculation and measurement of the vibration stress in combined high and low cycle fatigue tests[J]. Gas Turbine Experiment and Research, 2010,4:22-25(in Chinese).

Characteristics and application of bending moments of helicopter rotor shaft

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 20

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Dazhi SUN, Xi CHEN, Weicheng BAO, Wei BIAN, Qijun ZHAO. Interferences of high-speed helicopter fuselage on aerodynamic and aeroacoustic source characteristics of propeller [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529142-529142.
[2]	Zixu WANG, Pan LI, Ke LU, Zhenhua ZHU, Renliang CHEN. Optimized design of trim strategy for coaxial rigid rotor high-speed helicopter [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529069-529069.
[3]	Yurou DAI, Jian LI, Xiaopeng XUE, Wei RONG. Aerodynamic characteristics of supersonic disk-gap-band parachute with different reefing ways [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(7): 128811-128811.
[4]	Tongzhou GAO, Xiaofan HE, Xiaolei WANG, Ziguang LI, Zhentao ZHU, Zhixin ZHAN. Fatigue life prediction of 2014-T6 aluminum alloy based on CDM theory and SVM model [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(7): 228952-228952.
[5]	Ruixian MA, Xin WANG, Kaiming WANG, Bin LI, Mingfu LIAO, Siji WANG. Rubbing experimental study on labyrinth and rubber⁃coated case for aero⁃engines [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(4): 628350-628350.
[6]	Hongbo WANG, Yu ZENG, Dapeng XIONG, Yixin YANG, Mingbo SUN. Improvement of shock wave and compressibility effects in SST turbulence model [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(3): 128694-128694.
[7]	Fuze ZHANG. Determination of the calendar life of the whole aircraft and the relevant issues [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(3): 229863-229863.
[8]	Kelei WANG, Zhou ZHOU, Jiahao GUO, Minghao LI. Propulsive/aerodynamic coupled characteristics of distributed-propulsion-wing during forward flight [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(2): 128643-128643.
[9]	Bowei MENG, Hu MA, Zhenjuan XIA, Changsheng ZHOU. Numerical study on characterization of integrated rotating detonation combustor and turbine guide vane [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(10): 129223-129223.
[10]	Lifen ZHANG, Bangtuo YU, Hongli XU, Jianhui ZHAO, Zhiyuan XU, Zhenxia LIU. Icing and pressure drop loss on helicopter multi-tube separator [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(S2): 729303-729303.
[11]	Dazhi SHI, Weimin SANG, Shijie LI, Bo AN. Numerical simulation of water droplet impact characteristics on icing surfaces based on LBM [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(S2): 729192-729192.
[12]	Zhen WEI, Xiufang LIU, Fuhao ZHONG, Jiajun CHEN, Qingshuo MIAO, Yu HOU. Visual experimental investigation on melting characteristics of minuscule ice crystal particles [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(S2): 729301-729301.
[13]	Xiaoyu SUO, Yi JIANG, Wenjie WANG, Dianrong GAO, Xinyu ZHANG. Cavitation flow characteristics and optimization of high-pressure pumps in hydraulic system of aircraft control surfaces [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(9): 127402-127402.
[14]	Haolei MOU, Jiang XIE, Zhenyu FENG, Kun CHENG, Yi LIU. Crashworthiness characteristics analysis of typical fuselage section of large transport aircraft [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(9): 227512-227512.
[15]	Siyuan CHANG, Yao XIAO, Guangli LI, Zhongwei TIAN, Kaikai ZHANG, Kai CUI. Effect of wing dihedral and anhedral angles on hypersonic aerodynamic characteristics of high-pressure capturing wing configuration [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(8): 127349-127349.