基于Copula函数的单冷贮备串联结构可靠性分析

doi:10.7527/S1000-6893.2014.0042

Abstract

Abstract:

The traditional reliability model cannot well reflect the effect of performance dependency of units on the reliability of systems and neglect the problems of initial composite reliability. Confining the system to series connection, the system reliability and mean time to failure (MTTF) of a series dependence system with multi-subsystems and one cold standby unit are studied. The Copula function is applied to describing the performance dependence among units, and the reliability models of dependence units with initial reliability and cold standby unit are inferred based on the theories of reliability statistics and conditional probability, the expression for the MTTF of the series system is also obtained. Based on the fact that Farlie-Gumbel-Morgenstern (FGM) Copula function and marginal lifetime is exponential distribution, a system with two-dependent-unit in series and a single cold standby unit is taken as an example; the effect on the reliability of system because of the dependence degree is studied and the system reliability can be expressed as the linear combination of exponential reliability functions with different failure rates. The validity of the modeling method is verified and the presented method provides the theoretical basis for reliability design of system and management from a practical point of view.

Key words: Copula function, performance dependence, reliability, cold standby unit, mean time to failure

CLC Number:

ZHANG Yongjin, SUN Youchao, LU Zhong. Copula Function-based Reliability Analysis of a Series System with a Single Cold Standby Unit[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2014, 35(8): 2207-2216.

References

[1] Wang Z, Xie L Y, Zhang J Y. Reliability model of system with common cause failure under repeated random load[J]. Acta Aeronautica et Astronautica Sinica, 2007, 28(S1): S116-S120. (in Chinese) 王正, 谢里阳, 张君一. 载荷多次作用下的共因失效系统可靠性模型[J]. 航空学报, 2007, 28(S1): S116-S120.

[2] Challa V, Rundle P, Pecht M. Challenges in the qualification of electronic components and systems[J]. IEEE Transactions on Device and Materials Reliability, 2013, 13(1): 26-35.

[3] Tan L, Yang J, Cheng Z J, et al. Optimal replacement policy for cold standby system[J]. Chinese Journal of Mechanical Engineering, 2011, 24(2): 316-322.

[4] Kotz S, Lai C D, Xie M. On the effect of redundancy for systems with dependent components[J]. IIE Transactions, 2003, 35(12): 1103-1110.

[5] Wang Z, Xie L Y. Dynamic reliability model of k-out-of-n system with dependent failure[J]. Chinese Journal of Mechanical Engineering, 2008, 44(6): 72-78.

[6] Wang Z, Kang R, Xie L Y. Reliability modeling of systems with dependent failure when the life measured by the number of loadings[J]. Chinese Journal of Mechanical Engineering, 2010, 46(6): 188-194.

[7] Zhou J Y, Xie L Y, Qian W X. Reliability analysis on structural systems with load dependency[J]. Chinese Journal of Mechanical Engineering, 2008, 44(5): 45-50.

[8] Navarro J, Spizzichino F. Comparisons of series and parallel systems with components sharing the same copula[J]. Applied Stochastic Models in Business and Industry, 2010, 26(6): 775-791.

[9] Jia X, Cui L, Yan J. A study on the reliability of consecutive k-out-of-n: G systems based on copula[J]. Communications in Statistics: Theory and Methods, 2010, 39(13): 2455-2472.

[10] Eryilmaz S. Estimation in coherent reliability systems through copulas[J]. Reliability Engineering and System Safety, 2011, 96(5): 564-568.

[11] Yu H Y, Chu C B, Eric C, et al. Reliability optimization of a redundant system with failure dependencies[J]. Reliability Engineering & System Safety, 2007, 92(12): 1627-1634.

[12] Wang C N, Xing L D, Gregory L. Competing failure analysis in phased-mission systems with functional dependence in one of phases[J]. Reliability Engineering & System Safety, 2012, 108(11): 90-99.

[13] Malinowski J. A Monte Carlo method for estimating reliability parameters of a complex repairable rechnical system with inter-component dependencies[J]. IEEE Transactions on Reliability, 2013, 62(1): 256-266.

[14] Bayramoglu I. Reliability and mean residual life of complex systems with two dependent components per-element[J]. IEEE Transactions on Reliability, 2013, 62(1): 276-285.

[15] Anastasiadis S, Arnold R, Hayakawa Y. Multicomponent systems with multiplicative aging and dependent failures[J]. IEEE Transactions on Reliability, 2013, 62(1): 286-295.

[16] Hong H P, Zhou W, Zhang S, et al. Optimal condition-based maintenance decisions for systems with dependent stochastic degradation of components[J]. Reliability Engineering & System Safety, 2014, 121(1): 276-288.

[17] Serkan E, Fatih T. On reliability analysis of a two-dependent-unit series system with a standby unit[J]. Applied Mathematics and Computation, 2012, 218(15): 7792-7797.

[18] Nelsen R B. An introduction to copulas[M]. 2nd ed. New York: Springer, 2006: 17-20.

[19] Tang X S, Li D Q, Rong G, et al. Impact of copula selection on geotechnical reliability under incomplete probability information[J]. Computers and Geotechnics, 2013, 49(4): 264-278.

[20] Sun Y B. Reliability of interconnected system research based on Copula. Chongqing: Chongqing University, 2010.(in Chinese) 孙永波. 基于Copula的关联系统可靠性研究. 重庆: 重庆大学, 2010.

[21] Farlie D J. The performance of some correlation coefficients for a general bivariate distribution[J]. Biometrika, 1960, 47(3-4): 307-323.

Copula Function-based Reliability Analysis of a Series System with a Single Cold Standby Unit

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Yulian GONG, Jianguo ZHANG, Zhigang WU, Guangyuan CHU, Xiaoduo FAN, Ying HUANG. Reliability algorithm of composite structure based on active learning basis-adaptive PC-Kriging model [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(8): 228982-228982.
[2]	Fan ZHANG, Bohan CHENG, Peng WANG, Lei DONG. A two-stage degradation model and reliability analysis related to degradation of binary load-sharing systems [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(7): 229046-229046.
[3]	Xiaofeng XUE, Miaoyan ZHAO, Qianyi DU, Yunwen FENG, Junling FAN, Ting JIAO. Detection reliability based on quantification of human and environmental factors [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(6): 228859-228859.
[4]	Xinqian ZHENG, Junying WANG, Weina HUANG, Yu FU, Ronghui CHENG, Hongyang XIONG. Uncertainty⁃based design system for aeroengines [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(7): 27099-027099.
[5]	Benqi SUN, Qiang YANG, Zhili SUN, Shujun LI, Hongkun MA, Ruonan WANG. A probabilistic evaluation model for configuration transformation ability of planar constrained metamorphic mechanisms [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(4): 426843-426843.
[6]	Fan ZHANG, Zijing SUN, Guosong XIAO, Jiachen LIU, Peng WANG. Reliability analysis for multi-phased mission of HUD system based on intuitionistic fuzzy Bayesian network [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(4): 226853-226853.
[7]	Mengqi GU, Jiacai ZHU, Wanlin GUO, Song XUE. Prospects for fatigue durability and reliability of reusable launch vehicle structures [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(23): 628299-628299.
[8]	Lechang YANG, Chenxing WANG. Parameter calibration and reliability analysis of an aero-engine rotor based on multi-source heterogeneous information [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(23): 228575-228575.
[9]	Yunwen FENG, Jiaqiang TANG, Chenghui FENG, Xianmin CHEN, Xiaofeng XUE. Reliability study of multiple load path lug based on load⁃sharing theory [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(20): 228528-228528.
[10]	Feng JIANG, Huacong LI, Jiangfeng FU, Linxiong HONG. A RBF and active learning combined method for structural non-probabilistic reliability analysis [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(2): 226667-226667.
[11]	Yunwen FENG, Xinyi LIN, Xiaofeng XUE, Xiang YANG, Jiaqi LIU. Design of civil aircraft explosion-proof structure for high reliable one-way blasting [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(18): 228297-228297.
[12]	Qing GUO, Deming GUAN. Human factor reliability prediction model for civil aircraft maintenance task analysis [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(16): 228051-228051.
[13]	Kai SONG, Chi ZHANG, Chenhui YAN, Ning NING, Junling FAN, Rongbiao WANG. Reliability of aero-engine wheel model assisted eddy current testing based on two-parameter representation [J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(13): 227866-227866.
[14]	Wanying YUN, Zhenzhou LYU. An efficient surrogate method for analyzing parameter global reliability sensitivity [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(12): 227670-227670.
[15]	CHEN Zhiyuan, LI Luyi. Efficient methods for reliability sensitivity analysis of inputs with distribution parameter uncertainty [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2022, 43(9): 325881-325881.