直升机后缘襟翼驱动器迟滞现象仿真与抑制

doi:10.7527/S1000-6893.2019.23384

Abstract

Abstract: Piezoelectric actuators are used to drive trailing-edge flaps of helicopters, but hysteresis of these actuators can degrade the vibration control performance of the active rotor. To solve this problem, hysteresis modeling and suppression are studied for a piezoelectric actuator. The hysteresis curves of this actuator at different frequencies are measured, and the Bouc-Wen model is utilized to model its rate-dependent hysteresis. Particle Swarm Optimization (PSO) algorithm is selected to identify the unknown parameters of the Bouc-Wen model, and a good agreement is shown between experimental results and model outputs for a range of frequencies from 10 Hz to 60 Hz, demonstrating that the established model is capable of simulating the actuator’s dynamic hysteresis. A compound control scheme combining feedforward control based on inverse Bouc-Wen model and PID feedback control is established, and experimental results show that hysteresis of the piezoelectric actuator is suppressed remarkably at frequency range of 10 Hz to 60 Hz. Hysteresis model of the piezoelectric actuator is incorporated into helicopter rotor dynamic model to study the effect of actuator hysteresis on vibration control performance. Simulations of a model rotor with trailing-edge flaps are conducted in moderate speed forward flight condition. The results show that hysteresis can result in performance degradation of the trailing-edge flaps, while the compound control algorithm has the potential to improve the control authority of active rotor.

Key words: helicopter, rotor, trailing-edge flap, piezoelectric actuator, hysteresis

CLC Number:

V211.52

ZHOU Jinlong, DONG Linghua, YANG Weidong. Hysteresis modeling and suppression of piezoelectric actuator for helicopter trailing-edge flaps[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(4): 223384-223384.

References 26

[1]	STRAUB F K, ANAND V R, BIRCHETTE T S, et al. SMART rotor development and wind tunnel test:ARC-E-DAA-TN453[R]. Washington,D.C.:NASA,2009.
[2]	RABOURDIN A, MAURICE J B, DIETERICH O, et al. Blue pulse active rotor control at airbus helicopters-new EC145 demonstrator and flight test results[C]//AHS 70th Annual Forum,2014:1-24.
[3]	DIETERICH O, RABOURDIN A, MAURICE J B, et al. Blue Pulse active rotor control by trailing edge flaps at airbus helicopters[C]//41st European Rotorcraft Forum, 2015:1-13.
[4]	STRAUB F K, BYRNS J EV. Application of higher harmonic blade feathering on the oh-6a helicopter for vibration reduction:NASA Contractor Report 4031[R]. Washington,D.C.:NASA, 1986.
[5]	HABER A, JACKLIN S A, SIMONE G. Development manufacturing and component testing of an individual blade control system for a uh-60 helicopter rotor[C]//American Helicopter Society Aerodynamics, Acoustics, and Evaluation Technical Specialists Meeting, 2002:1-10.
[6]	ARNOLD U T P. Recent flight test results from the ch-53g helicopter[C]//29th European Rotorcraft Forum, 2003:1-15.
[7]	ARNOLD U T P, FURST D. Closed loop IBC results from ch-53g flight tests[J]. Aerospace Science and Technology, 2005, 9(5):421-435.
[8]	HALL S R, PRECHTL E F. Preliminary testing of a Mach-scaled active rotor blade with a trailing-edge servo-flap[C]//Smart Structures and Materials 1999:Smart Structures and Integrated Systems, 1999:14-21.
[9]	PRECHTL E F, HALL S R. Closed-loop vibration control experiments on a rotor with blade mounted actuation[C]//41st Structures, Structural Dynamics, and Materials Conference and Exhibit. Reston,VA:AIAA, 2000:1714-1728.
[10]	ELIF A E, PFALLER R, DENECKE U, et al. Piezo active rotor blade-challenges and solutions[C]//American Helicopter Society 69th Annual Forum. Reston,VA:AIAA, 2013:1-14.
[11]	LEE T, CHOPRA I. Design of piezostack-driven trailing-edge flap actuator for helicopter rotors[J].Smart Materials and Structures, 2001,10(1):15-24.
[12]	LEE T, CHOPRA I. Design issues of a high-stroke, on-blade piezostack actuator for a helicopter rotor with trailing-edge flaps[J]. Journal of Intelligent Material Systems and Structures, 2000, 11(5):328-342.
[13]	CROZIER P, LECONTE P, DELRIEUX Y, et al. Wind-tunnel tests of a helicopter rotor with active flaps[C]//32nd European Rotorcraft Forum, 2006:1-16.
[14]	VISWAMURTHY S R, RAO A K, GANGULI R. Dynamic hysteresis of piezoelectric stack actuators used in helicopter vibration control:Experiments and simulations[J]. Smart Materials and Structures, 2007, 16(4):1109-1119.
[15]	VISWAMURTHY S R, GANGULI R. Effect of piezoelectric hysteresis on helicopter vibration control using trailing-edge flaps[J]. Journal of Guidance, Control, and Dynamics, 2006, 29(5):1201-1209.
[16]	VISWAMURTHY S R, GANGULI R. Modeling and compensation of piezoelectric actuator hysteresis for helicopter vibration control[J]. Sensors and Actuators A:Physical, 2007, 135(2):801-810.
[17]	MALLICK R, GANGULI R, BHAT M S. An experimental and numerical study of piezoceramic actuator hysteresis in in helicopter active vibration control[J]. Journal of Aerospace Engineering, 2014, 228(5):690-705.
[18]	MUIR E R, LIU L, FRIEDMANN P P, et al. Hysteresis characterization in piezoceramic stack actuator and its influence on vibration and noise reduction in helicopters using actively controlled flaps[C]//51st AIAA/ASME/ASCE/AHS/ASC Structures, Structural Dynamics, and Materials Conference. Reston,VA:AIAA, 2010:1-20.
[19]	MUIR E R, LIU L, FRIEDMANN P P, et al. Effect of piezoelectric actuator hysteresis on helicopter vibration and noise reduction[J]. Journal of Guidance, Control, and Dynamics, 2012, 35(4):1299-1311.
[20]	HASSANI V, TJAHJOWIDODO T, THANH N D. A survey on hysteresis modeling identification and control[J]. Mechanical Systems and Signal Processing, 2014, 49(1-2):209-233.
[21]	CHANG C M, STRANO S, TERZO M. Modeling of hysteresis in vibration control systems by means of Bouc-Wen model[J]. Shock and Vibration, 2016, 2016:1-14.
[22]	FUJII F, TATEBATAKE K I, MORITA K, et al. A Bouc-Wen model-based compensation of the frequency-dependent hysteresis of a piezoelectric actuator exhibiting odd harmonic oscillation[J]. Actuators, 2018, 7(3):1-16.
[23]	杨晓京,彭芸浩,李尧.压电微位移台的动态迟滞建模及实验验证[J].光学精密工程, 2016, 24(9):2255-2261. YANG X J, PENG Y H, LI Y. Dynamic hysteresis modeling and experimental verification of piezoelectric positioning stage[J]. Optics and Precision Engineering, 2016, 24(9):2255-2261(in Chinese).
[24]	刘士明,杨卫东,虞志浩,等.带后缘小翼的旋翼振动载荷计算[J].航空动力学报, 2016, 31(6):1496-1503. LIU S M, YANG W D, YU Z H, et al. Vibratory loads prediction of rotor with trailing edge flaps[J]. Journal of Aerospace Power, 2016, 31(6):1496-1503(in Chinese).
[25]	周金龙,董凌华,杨卫东,等.基于加权最小二乘法辨识的后缘襟翼智能旋翼振动载荷闭环控制仿真研究[J].振动与冲击, 2019, 38(4):237-244. ZHOU J L, DONG L H, YANG W D, et al. Closed-loop vibration control simulation of helicopter active rotor with trailing-edge flaps based on weighted-least-squares-error identification method[J]. Journal of Vibration and Shock, 2019, 38(4):237-244(in Chinese).
[26]	HEFFERNAN P M, GAUBERT M. Structural and aerodynamic loads and performance measurements of an SA349/2 helicopter with an advanced geometry rotor:NASA-TM-88370[R].Washington,D.C.:NASA, 1986.

Hysteresis modeling and suppression of piezoelectric actuator for helicopter trailing-edge flaps

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 26

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Jinchao MA, Yang LU, Liangquan WANG, Kuihui SONG. Active control test of tiltrotor near-field aeroacoustics based on higher harmonic control [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 528602-528602.
[2]	Bo LI, Xiao WANG. Dynamic modeling and modal analysis of coaxial rotors/auxiliary propeller/drive train coupled system [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 528945-528945.
[3]	Qi LIU, Yongjie SHI, Zhiyuan HU, Guohua XU. Parameter effects analysis on aerodynamic and aeroacoustic characteristics of coaxial rigid rotor [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 528856-528856.
[4]	Fengying ZHENG, Zhimin SHEN, Yaqin LI, Kaizhao XU, Xinhua WANG. Gain adaptive multi-mode switching control for coaxial high-speed helicopter [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529088-529088.
[5]	Zhuangzhuang CUI, Xin YUAN, Guoqing ZHAO, Simeng JING, Qijun ZHAO. Influence of control strategy on forward flight performance of coaxial rigid rotor high⁃speed helicopters [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529256-529256.
[6]	Dazhi SUN, Xi CHEN, Weicheng BAO, Wei BIAN, Qijun ZHAO. Interferences of high-speed helicopter fuselage on aerodynamic and aeroacoustic source characteristics of propeller [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529142-529142.
[7]	Pengpeng SUN, Ping’an LIU, Feng FAN, Wei ZENG. Aerodynamic interaction characteristics of coaxial rigid rotor⁃fuselage in hover condition [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529284-529284.
[8]	Jiaqi LIU, Rongqian CHEN, Jinhua LOU, Xu HAN, Hao WU, Yancheng YOU. Aerodynamic shape optimization of high-speed helicopter rotor airfoil based on deep learning [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529828-529828.
[9]	Chang WANG, Long HE, Dongxia XU, Min TANG, Shuai MA, Ximing WU. Flow control drag reduction of hub on coaxial rigid rotor aircraft [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529084-529084.
[10]	Changhao LIU, Yihua CAO, Xiaomeng MEI, Maosheng WANG, Guanglin ZHANG. Transport effectiveness evaluation of high⁃speed helicopters [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 530182-530182.
[11]	Yuqing QIU, Yan LI, Jinxi LANG, Yuxian LIU, Zhong WANG. Robust adaptive attitude control of high-speed helicopters in transition mode [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529927-529927.
[12]	Weiguo ZHANG, Min TANG, Jie WU, Xianmin PENG, Guichuan ZHANG, Bowen NIE, Liangquan WANG, Chaoqun LI. Overview of wind tunnel test research on tiltrotor aircraft [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 530114-530114.
[13]	Zonghui WANG, Yunjun YANG, Hongrui ZHAO, Xuechen WANG. Aerodynamic optimization design of tiltrotor under multiple flight conditions [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529024-529024.
[14]	Yilan ZENG, Dong HAN, Zhuangzhuang LIU, Xin ZHOU. Driving rotation characteristics of a compound helicopter’s rotor undergoing upwash in high⁃speed flight [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529061-529061.
[15]	Shaoqiang HAN, Wenping SONG, Zhonghua HAN, Jianhua XU. High-accuracy numerical-simulation of unsteady flow over high-speed coaxial rigid rotors [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529064-529064.