地效环境下悬停状态直升机旋翼桨/涡干扰噪声特性

doi:10.7527/S1000-6893.2023.29196

Abstract

Abstract:

To grasp rotor aeroacoustic radiation characteristics during helicopter flight close to the ground， firstly， based on the compressible Reynolds average Navier-Stokes equations and the Ffowcs Williams-Hawkings equations， a set of aerodynamic and aeroacoustic analysis method suitable for rotor/fuselage interaction in ground effect state was developed. The reliability of the established method was verified by comparing the ground effect test of Lynx tail rotor and the NASA rotor/fuselage interaction test with calculation results. Then， the influence of fuselage and hub on the rotor flowfield was investigated. It was found that the fuselage could change the rotor aerodynamic load distribution and increase the aeroacoustic radiation level of the intermediate order （8th–12th order）. The aeroacoustic contribution of the blade middle section （r=0.4R–0.7R，R is the radius of rotor） could be weaken by the hub. Finally， the aerodynamic and aeroacoustic characteristics of the rotor at different heights （h） above the ground were investigated and a “critical ground height” with Blade/Vortex Interaction （BVI） noise was found. The results show that the rotor thrust and fuselage lift decrease with the increase of ground height. When h>1.8R， the influence of ground effect can be ignored. When h=0.6R， the inflow of the rotor will be changed by the blocking effect of the ground and the fuselage. Especially， load fluctuations are induced severely in the blade tip area and obvious BVI noise is received at the characteristic observation points. According to the time/frequency characteristics， this paper suggests a “critical ground height” of approximately 0.7R， which provides a reference for the noise suppression when the helicopter flies close to the ground.

Key words: rotor aerodynamic noise, FW-H equations, rotor/fuselage interaction, in ground effect, blade/vortex interaction noise

CLC Number:

V211.52

Weiqi WANG, Xi CHEN, Qijun ZHAO. Hovering helicopter rotor blade/vortex interaction noise characteristics in ground effect environment[J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(12): 129196-129196.

Figures/Tables 26

Fig.1

Fig.2

Fig.3

Table 1

Rotor cyclic pitch

$μ$	$α s$ /（°）	$θ 0$ /（°）	$θ 1 c$ /（°）	$θ 1 s$ /（°）
0.01	0	11.8	0.1	-0.2
0.05	0	11.9	1.3	-1.3

Table 1

Fig.4

Fig.5

Fig.6

Fig.7

Fig.8

Fig.9

Fig.10

Fig.11

Fig.12

Fig.13

Fig.14

Fig.15

Fig.16

Fig.17

Fig.18

Fig.19

Fig.20

Fig.21

Fig.22

Fig.23

Fig.24

Fig.25

References 30

1	MILLUZZO J I III， LEISHMAN J G. Vortical sheet behavior in the wake of a rotor in ground effect［J］. AIAA Journal， 2017， 55（1）： 24-35.
2	MOUSHEGIAN A M， SMITH M J. Physics and accuracy of dual-solver simulations of rotors in ground effect［J］. Journal of the American Helicopter Society， 2023， 68（1）： 1-16.
3	SUGIURA M， TANABE Y， SUGAWARA H， et al. Numerical simulations and measurements of the helicopter wake in ground effect［J］. Journal of Aircraft， 2016， 54（1）： 209-219.
4	BARDERA MORA R， MATÍAS GARCÍA J C. Helic-opter rotor ground effect and frigate interaction inve-stigated by particle image velocimetry［J］. AIAA Journal， 2021， 60（1）： 129-143.
5	胡健平，徐国华，史勇杰，等. 基于CFD-DEM耦合数值模拟的全尺寸直升机沙盲形成机理［J］. 航空学报， 2020， 41（3）： 123363.
	HU J P， XU G H， SHI Y J， et al. Formation mechanism of brownout in full-scale helicopter based on CFD-DEM couplings numerical simulation［J］. Acta Aeronautica et Astronautica Sinica， 2020， 41（3）： 123363 （in Chinese）.
6	覃燕华，朱清华，邵松. 共轴双旋翼悬停地面效应气动特性分析［J］. 南京航空航天大学学报， 2015， 47（2）： 266-274.
	QIN Y H， ZHU Q H， SHAO S. Aerodynamic characteristics analysis for hovering coaxial rotors in ground effect［J］. Journal of Nanjing University of Aeronautics & Astronautics， 2015， 47（2）： 266-274 （in Chinese）.
7	FRADENBURGH E A. The helicopter and the ground effect machine［J］. Journal of the American Helicopter Society， 1960， 5（4）： 24-33.
8	HAYDEN J S. The effect of the ground on helicopter hovering power required［C］∥ Proceedings of 32nd National Forum of the American Helicopter Society. 1976： 1-11.
9	LEE T E， LEISHMAN J G， RAMASAMY M. Fluid dynamics of interacting blade tip vortices with a ground plane［J］. Journal of the American Helicopter Society， 2010， 55（2）： 22005-2200516.
10	NATHAN N D， GREEN R B. The flow around a model helicopter main rotor in ground effect［J］. Experiments in Fluids， 2012， 52（1）： 151-166.
11	SILWAL L， BHAGWAT M， RAGHAV V. Aerodynamic interactions of counter-rotating coaxial rotors hovering in ground effect［J］. Journal of Aircraft， 2022， 59（6）： 1416-1425.
12	辛冀，陈仁良，李攀. 地面效应中垂直起降状态旋翼的气动特性计算［J］. 南京航空航天大学学报， 2014， 46（3）： 433-442.
	XIN J， CHEN R L， LI P. Aerodynamics characteristics prediction for axial flying rotor in ground effect［J］. Journal of Nanjing University of Aeronautics & Astronautics， 2014， 46（3）： 433-442 （in Chinese）.
13	谭剑锋，周天熠，王畅，等. 旋翼地面效应的气动建模与特性［J］. 航空学报， 2019， 40（6）： 122602.
	TAN J F， ZHOU T Y， WANG C， et al. Aerodynamic model and characteristics of rotor in ground effect［J］. Acta Aeronautica et Astronautica Sinica， 2019， 40（6）： 122602 （in Chinese）.
14	PASQUALI C， GENNARETTI M， BERNARDINI G， et al. State-space dynamic inflow modelling for hovering rotors in fixed- and moving-ground effect［J］. Aerospace Science and Technology， 2023， 140： 108414.
15	康宁，孙茂. 旋翼近地飞行时诱导速度的Navier-Stokes方程计算［J］. 空气动力学学报， 1998， 16（2）： 221-225.
	KANG N， SUN M. Navier-Stokes calculations of induced velocity of a rotor in forward flight with ground effects［J］. Acta Aerodynamica Sinica， 1998， 16（2）： 221-225 （in Chinese）.
16	朱明勇，招启军，王博. 基于CFD和混合配平算法的直升机旋翼地面效应模拟［J］. 航空学报， 2016， 37（8）： 2539-2551.
	ZHU M Y， ZHAO Q J， WANG B. Simulation of helicopter rotor in ground effect based on CFD method and hybrid trim algorithm［J］. Acta Aeronautica et Astronautica Sinica， 2016， 37（8）： 2539-2551 （in Chinese）.
17	叶靓，招启军，徐国华. 基于非结构嵌套网格方法的旋翼地面效应数值模拟［J］. 航空学报， 2009， 30（5）： 780-786.
	YE L， ZHAO Q J， XU G H. Numerical simulation on flowfield of rotor in ground effect based on unstructured embedded grid method［J］. Acta Aeronautica et Astronautica Sinica， 2009， 30（5）： 780-786 （in Chinese）.
18	卢丛玲，祁浩天，徐国华，等. 共轴刚性旋翼悬停状态地面效应气动特性［J］. 航空学报， 2019， 40（12）： 123055.
	LU C L， QI H T， XU G H， et al. Aerodynamic characteristics of hovering coaxial rigid rotor in ground effect［J］. Acta Aeronautica et Astronautica Sinica， 2019， 40（12）： 123055 （in Chinese）.
19	HWANG J Y， CHOI J H， KWON O J. Assessment of S-76 rotor hover performance in ground effect using an unstructured mixed mesh method［C］∥ 54th AIAA Aerospace Sciences Meeting. Reston： AIAA， 2016.
20	SILVA P A S F， TSOUTSANIS P， ANTONIADIS A F. Numerical investigation of full helicopter with and without the ground effect［J］. Aerospace Science and Technology， 2022， 122： 107401.
21	SMITH B， LYRINTZIS A， INSTITUTE R P， et al. eVTOL rotor noise in ground effect［C］∥ Proceedings of the Vertical Flight Society 77th Annual Forum. 2021： 77⁃90.
22	ZHAO Q J， ZHAO G Q， WANG B， et al. Robust Navier-Stokes method for predicting unsteady flowfield and aerodynamic characteristics of helicopter rotor［J］. Chinese Journal of Aeronautics， 2018， 31（2）： 214-224.
23	CHEN X， ZHANG K， ZHAO Q J， et al. Numerical analysis of rotor aeroacoustic characteristics during collective pitch aperiodic variation in hover［J］. Aerospace Science and Technology， 2022， 124： 107411.
24	招启军，朱正，原昕. 桨叶外形对共轴刚性旋翼悬停性能影响的CFD分析［J］. 南京航空航天大学学报， 2017， 49（5）： 653-661.
	ZHAO Q J， ZHU Z， YUAN X. CFD analyses on effects of blade shape on hover performance of coaxial rigid rotors［J］. Journal of Nanjing University of Aeronautics & Astronautics， 2017， 49（5）： 653-661 （in Chinese）.
25	FFOWCS WILLIAMS J E， HAWKINGS D L. Sound generation by turbulence and surfaces in arbitrary motion［J］. Mathematical and Physical Sciences， 1969， 264（1151）： 321-342.
26	FARASSAT F. Linear acoustic formulas for calculation of rotating blade noise［J］. AIAA Journal， 1981， 19（9）： 1122-1130.
27	LIGHT J S. Tip vortex geometry of a hovering helicopter rotor in ground effect［J］. Journal of the American Helicopter Society， 1993， 38（2）： 34-42.
28	CHEESEMAN I C， BENNETT W E. The effect of the ground on a helicopter rotor in forward flight： ARC-RM-3021［R］. London： Annual Technical Report of the Aeronautical Research Council， 1955.
29	MINECK R E， GORTON S A. Steady and periodic pressure measurements on a generic helicopter fuselage model in the presence of a rotor： NASA/TM-2000-210286［R］. Hampton： NASA Langley Technical Report Server， 2000.
30	BOXWELL D A， SCHMITZ F H， SPLETTSTOESSER W R， et al. Helicopter model rotor-blade vortex interaction impulsive noise： Scalability and parametric variations［J］. Journal of the American Helicopter Society， 1987， 32（1）： 3-12.

[1]	Dazhi SUN, Xi CHEN, Weicheng BAO, Wei BIAN, Qijun ZHAO. Interferences of high-speed helicopter fuselage on aerodynamic and aeroacoustic source characteristics of propeller [J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(9): 529142-529142.
[2]	TONG Hang, LI Lin, MAO Luqin, XIANG Kangshen, QIAO Weiyang. Tonal noise reduction of a high-speed single axial fan with wavy leading-edge stator [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(10): 123565-123565.
[3]	CHEN Siyu, ZHAO Qijun, NI Tongbing, ZHU Zheng. Rotor noise reduction mechanism and parameter analysis of HHC method [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2017, 38(10): 121000-121000.
[4]	ZHU Mingyong, ZHAO Qijun, WANG Bo. Simulation of helicopter rotor in ground effect based on CFD method and hybrid trim algorithm [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2016, 37(8): 2539-2551.
[5]	ZHU Zheng, ZHAO Qijun. Optimization design method for rotor blade-tip shape with low HSI noise characteristics [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2015, 36(5): 1442-1452.
[6]	HAN Jinglong, CHEN Quanlong, YUN Haiwei. Aeroelasticity of helicopters [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2015, 36(4): 1034-1055.
[7]	XIN Ji, LI Pan, CHEN Renliang. Free-wake Analysis of Hovering Rotor in Ground Effect [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2012, 33(12): 2161-2170.
[8]	Li Jun;Le Qiumin;Li Aiping. Weight Estimation of Wing in Ground Effect Craft [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2010, 31(6): 1164-1170.

Hovering helicopter rotor blade/vortex interaction noise characteristics in ground effect environment

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 26

References 30

Related Articles 8

Recommended Articles

Metrics

Comments