轴流风扇宽频噪声声功率实验研究

doi:10.7527/S1000-6893.2015.0080

Abstract

Abstract:

It is in urgent need for aircraft engine noise reduction research to find a kind of measurement technique for broadband noise determination in turbomachinery duct to guide the noise reduction design. In this paper, we use wall-flush annularly installed microphone array to measure the noise of axial fan and finally obtain the broadband sound power in duct by means of cross-spectra between measurement signals and reference signal and the application of singular value decomposition (SVD) method. The results show that this experimental technique enables the calculation of not only in-duct transmitted sound power for dominant tones, but also broadband noise over a wide frequency range; this method also helps to distinguishe between sound power transmitted in and against the direction of flow. Broadband noise results confirm that this method behaves fairly robust in loud background noise and hard wall reflection condition.

Key words: broadband noise, mode, array, turbomachinery, axial fan

CLC Number:

V231

XU Kunbo, QIAO Weiyang, WANG Liangfeng, TONG Fan. Experimental research of broadband sound power determination in axial fan[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2015, 36(9): 2939-2946.

References

[1] Qiao W Y. Aero-engine aeroacoustics[M]. Beijing: Bei-hang University Press, 2010: 1-8 (in Chinese). 乔渭阳. 航空发动机气动声学[M]. 北京: 北京航空航天大学出版社, 2010: 1-8.
[2] Enghardt L, Holewa A, Tapken U. Comparison of different analysis techniques to decompose a broad-band ducted sound field in its mode constituents[C]//Proceedings of the 13th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2007.
[3] Tyler J M, Sofrin T G. Axial flow compressor noise studies[J]. Transactions of the Society of Automotive Engineers, 1962, 70: 309-332.
[4] Enghardt L, Lowis C. Broadband sound power determination in flow ducts[C]//Proceedings of the 10th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2004.
[5] Lowis C R, Joseph P. A focused beamformer technique for separating rotor and stator-based broadband sources[C]//Proceedings of the 12th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2006.
[6] Sijtsma P. Using phased array beamforming to locate broadband noise sources inside a turbofan engine, NLR-TP-2006-320[R]. Cambridge, MA: AARC Engine Noise Phased Array Workshop, 2006.
[7] Sijtsma P. Feasibility of in-duct beamforming[C]//Proceedings of the 13th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2007.
[8] Dougherty R P, Walker B E, Sutliff D L. Locating and quantifying broadband fan sources using in-duct microphones[C]//Proceedings of the 16th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2010.
[9] Finez A, Leneveu R, Picard C, et al. In-duct acoustic source detection using acoustic imaging techniques[C]//Proceedings of the 19th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2013.
[10] Ian D, Bennett G J. Experimental investigations of coherence based noise source identification technique for turbomachinery applications-classic and novel techniques[C]//Proceedings of the 17th AIAA/CEAS Aeroacoustic Conference. Reston: AIAA, 2011.
[11] Pardowitz B, Tapken U, Knobloch K, et al. Core noise-identification of broadband noise source of a turbo-shaft engine[C]//Proceedings of the 20th AIAA/CEAS Aeroacoustic Conference. Reston: AIAA, 2014.
[12] Michalke A, Arnold F, Holste F. On the coherence of the sound field in a circular duct with uniform mean flow[J]. Journal of Sound and Vibration, 1996, 190(2): 261-271.
[13] Chung J Y. Rejection of flow noise using a coherence function method[J]. Journal of the Acoustical Society of America, 1977, 62(2): 338-395.
[14] Enghardt L, Moreau A, Tapken U, et al. Radial mode decomposition in the outlet of a LP turbine-estimation of the relative importance of broadband noise[C]//Proceedings of the 15th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2009.
[15] Moreau A, Enghardt L. Ranking of fan broadband noise sources based on an experimental parametric study[C]//Proceedings of the 15th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2009.
[16] Tapken U, Enghardt L. Optimization of sensor arrays for radial mode analysis in flow ducts[C]//Proceedings of the 12th AIAA/CEAS Aeroacoustics Conference. Reston: AIAA, 2006.
[17] Jürgens W, Tapken U, Pardowitz B, et al. Technique to analyze characteristics of turbomachinery broadband noise sources[C]//Proceedings of the 16th AIAA/CEAS Aeroacoustic Conference. Reston: AIAA, 2010.
[18] Jürgens W, Pardowitz B, Tapken U, et al. Separation of broadband noise sources in aeroengine ducts with respect to modal decomposition[C]//Proceedings of the 17th AIAA/CEAS Aeroacoustics Conference (32nd AIAA Aeroacoustics Conference), 2011.
[19] Arnold F. Experimental and numerical investigation on the performance and determination in flow canals[D]. Berlin: Fortschrift Berichte, 1999.
[20] Nelson P A, Yoon S H. Estimation of acoustic source strength by inverse methods: Part I, conditioning of the inverse problem[J]. Journal of Sound and Vibration, 2000, 233(4): 639-664.
[21] Kim Y, Nelson P A. Estimation of acoustic source strength within a cylindrical duct by inverse methods[J]. Journal of Sound and Vibration, 2004, 275(1): 391-413.

Experimental research of broadband sound power determination in axial fan

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Tinggao YANG, Yuping GAO, Minglei TONG, Bian LI, Chengshi ZHAO, Jintao LUO, Xingzhi ZHU, Fei WEI. Review on research progress of ensemble pulsar time-scale [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(3): 526443-526443.
[2]	Gongye YU, Weidong CAI, Minghui HU, Wencai LIU, Bo MA. Intelligent migration diagnosis of mechanical faults driven by hybrid fault mechanism and domain adaptation [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(2): 426800-426800.
[3]	Ping JIANG, Bingnan QU, Huaze DING, Runze MA, Wei HE. Optimal array structure for time difference direction finding based on improved particle swarm optimization [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(2): 326502-326502.
[4]	Fanmin MENG, Nuo MA, Wenchao MA, Junhui MENG, Wenguang LI. Wet modal analysis and tests for inflatable wing with swept air-beams [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(2): 227098-227098.
[5]	Shanjie XU, Hongqiang LYU, Zhongchen LIU, Yan LENG, Xuejun LIU. Data analysis of sonic boom test based on probability model [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(2): 626269-626269.
[6]	Feng JIANG, Huacong LI, Jiangfeng FU, Linxiong HONG. A RBF and active learning combined method for structural non-probabilistic reliability analysis [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(2): 226667-226667.
[7]	Zikang SU, Zhongnan XU, Chuntao LI, Haitong CHEN, Honglun WANG. Modeling and docking control of UAV aerial recovery in form of telescopic boom [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(1): 326315-326315.
[8]	Qian YANG, Xiaofeng GUO, Qin LI, Wei DONG. Hot air anti-icing performance estimation method based on POD and surrogate model [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(1): 626992-626992.
[9]	Junjie NIU, Weimin SANG, Dong LI, Lian HAO, Zelin WANG. Icing test flight area determination method based on surrogated model of water droplet collection [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(1): 627697-627697.
[10]	Qilei GUO, Weimin SANG, Junjie NIU, Ye YUAN. UAV flight strategy considering icing risk under complex meteorological conditions [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(1): 627518-627518.
[11]	Wei ZHANG, Binwen WANG, Junling FAN, Shaozheng ZHAN, Ting JIAO, Yu YANG. Ultrasonic nondestructive characterization of impact damage and compression after impact for CFRP based on multi-mode imaging [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(1): 426635-426635.
[12]	Deyang TIAN, Yi PING, Yesi CHEN, Weifang CHEN. Influence of physical and chemical models on electromagnetic wave propagation characteristics of flow field [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2022, 43(S2): 214-224.
[13]	Shaobo YAO, Lijian JIANG, Wenwen ZHAO, Zheng LU, Changju WU, Weifang CHEN. Numerical method of data-driven rarefied nonlinear constitutive relations coupled with clustering [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2022, 43(S2): 40-53.
[14]	Xudong ZHANG, Zheng LI, Hao DONG, Siyuan GAO, Zubi JI, Kaixin LI, Guanghui BAI. Drag reduction characteristics of opposing plasma synthetic jet in hypersonic flow [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2022, 43(S2): 115-123.
[15]	Zheng LI, Cong XU, Jian ZHANG, Mengmeng LI, Yilei MA, Guanghui BAI. Reverse jet flow control by plasma synthetic jet actuator in high speed flow field [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2022, 43(S2): 225-232.