自激振荡过程中喷嘴内部扰动的产生及传递机制

doi:10.7527/S1000-6893.2021.26523

Abstract

Abstract:

The gas-liquid swirl coaxial injector is one of the most important injection elements for liquid rocket engines. However， this kind of injector is likely to suffer from self-pulsation， which may induce combustion instability and could even seriously affect the development of engines. At present， the understanding of the unsteady flow process inside the injector during self-pulsation is still very limited. By means of experimental and numerical simulation， this paper systematically analyzes the movement and deformation trajectory of liquid sheet， the causes of self-pulsation and the transmission process of pressure disturbance inside the liquid-centered swirl coaxial injector. It is found that the pressure oscillation of the flow field inside the injector is caused by the periodic blockage of the liquid sheet in the recess chamber， and the pressure oscillation first occurs outside the liquid sheet in the recess chamber. After that， the pressure oscillation is transmitted upstream through the gas annular gap and the internal pressure swirl injector with a certain phase difference， resulting in the pressure oscillation of the annular gap gas and central gas core with the same frequency. When self-pulsation intensity is large enough， it will cause the pressure oscillation of the liquid manifold， and the oscillation frequency is consistent with the self-pulsation frequency.

Key words: self-pulsation, spray, pressure disturbance, transparent recess chamber, gas-liquid swirl coaxial injector

CLC Number:

V435

Xiao BAI, Pengjin CAO, Qinglian LI, Peng CHENG. Generation and transmission mechanisms of disturbance inside injector during self-pulsation[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2023, 44(4): 126523-126523.

Figures/Tables 14

Fig. 1

Fig. 2

Table 1

Fig. 3

Fig. 4

Fig. 5

Fig. 6

Fig. 7

Fig. 8

Fig. 9

Fig. 10

Fig. 11

Fig. 12

Fig. 13

References 34

1	BAI X， SHENG L Y， LI Q L， et al. Effects of annulus width and post thickness on self-pulsation characteristics for Liquid-Centered Swirl Coaxial Injectors［J］. International Journal of Multiphase Flow， 2020， 122： 103140.
2	徐顺. 气体中心型气液同轴离心式喷嘴动态雾化特性研究［D］. 长沙：国防科技大学， 2016.
	XU S. Research on the dynamic spray characteristics of the gas-centered swirl coaxial injector［D］. Changsha： National University of Defense Technology， 2016 （in Chinese）.
3	康忠涛，李向东，毛雄兵，等. 液体火箭发动机中气液同轴直流式喷嘴研究综述［J］. 航空学报， 2018， 39（9）： 022221.
	KANG Z T， LI X D， MAO X B， et al. Review on gas liquid shear coaxial injector in liquid rocket engine［J］. Acta Aeronautica et Astronautica Sinica， 2018， 39（9）： 022221 （in Chinese）.
4	IM J H， KIM D， YOON Y， et al. Self-pulsation characteristics of a swirl coaxial injector with various injection and geometric conditions［C］∥ 41st AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit. Reston： AIAA， 2005.
5	IM J H， KIM D， HAN P， et al. Self-pulsation characteristics of a gas-liquid swirl coaxial injector［J］. Atomization and Sprays， 2009， 19（1）： 57-74.
6	康忠涛. 气液同轴离心式喷嘴非定常雾化机理和燃烧特性研究［D］. 长沙：国防科技大学， 2016.
	KANG Z T. The unsteady atomization mechanism and combustion characteristics of gas-liquid swirl coaxial injector［D］. Changsha： National University of Defense Technology， 2016 （in Chinese）.
7	BAI X， CHENG P， LI Q L， et al. Effects of self-pulsation on combustion instability in a liquid rocket engine［J］. Experimental Thermal and Fluid Science， 2020， 114： 110038.
8	BAZAROV V G， LUL’KA L A. Self-pulsation of liquid flow in coaxial air stream［J］. Soviet Aeronautics， 1978， 3（1）： 14-18.
9	BAZAROV V G， YANG V. Liquid-propellant rocket engine injector dynamics［J］. Journal of Propulsion and Power， 1998， 14（5）： 797-806.
10	BAZAROV V. Self-pulsations in coaxial injectors with central swirl liquid stage［C］∥ 31st Joint Propulsion Conference and Exhibit. Reston： AIAA， 1995.
11	BAZAROV V. Non-linear interactions in liquid-propellant rocket engine injectors［C］∥ 34th AIAA/ASME/SAE/ASEE Joint Propulsion Conference and Exhibit. Reston： AIAA， 1998.
12	BAZAROV V. Influence of propellant injector stationary and dynamic parameters on high frequency combustion stability［C］∥ 32nd Joint Propulsion Conference and Exhibit. Reston： AIAA， 1996.
13	ZHOU J， HU X P， HUANG Y H， et al. Flowrate and acoustics characteristics of coaxial swirling injector of hydrogen/oxygen rocket engine［C］∥ 32nd Joint Propulsion Conference and Exhibit. Reston： AIAA， 1996.
14	SASAKI M， SAKAMOTO H， TAKAHASHI M， et al. Comparative study of recessed and non-recessed swirl coaxial injectors［C］∥ 33rd Joint Propulsion Conference and Exhibit. Reston： AIAA， 1997.
15	HUANG Y H， ZHOU J， HU X P， et al. Acoustic model for the self-oscillation of coaxial swirl injector［C］∥ 33rd Joint Propulsion Conference and Exhibit. Reston： AIAA， 1997.
16	黄玉辉，周进，胡小平，等. 气液同轴式喷嘴自激振荡的试验现象和声学模型及对火箭发动机不稳定燃烧的影响［J］. 声学学报， 1998， 23（5）： 459-465.
	HUANG Y H， ZHOU J， HU X P， et al. Experiment and acoustic model for the self-oscillation of coaxial swirl injector and its influence to combustion of liquid rocket engine［J］. Acta Acustica， 1998， 23（5）： 459-465 （in Chinese）.
17	BAI X， LI Q L， CHENG P， et al. Investigation of self-pulsation characteristics for a liquid-centered swirl coaxial injector with recess［J］. Acta Astronautica， 2018， 151： 511-521.
18	IM J H， YOON Y. The effects of the ambient pressure on self-pulsation characteristics of a gas/liquid swirl coaxial injector［C］∥ 44th AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit. Reston： AIAA， 2008.
19	BAI X， CHENG P， SHENG L Y， et al. Effects of backpressure on self-pulsation characteristics of liquid-centered swirl coaxial injectors［J］. International Journal of Multiphase Flow， 2019， 116： 239-249.
20	YANG L J， GE M H， ZHANG M Z， et al. Spray characteristics of recessed gas-liquid coaxial swirl injector［J］. Journal of Propulsion and Power， 2008， 24（6）： 1332-1339.
21	KANG Z T， LI Q L， CHENG P， et al. Effects of recess on the self-pulsation characteristics of liquid-centered swirl coaxial injectors［J］. Journal of Propulsion and Power， 2016， 32（5）： 1124-1132.
22	LI Q L， KANG Z T， ZHANG X Q， et al. Effect of recess length on the spray characteristics of liquid-centered swirl coaxial injectors［J］. Atomization and Sprays， 2016， 26（6）： 535-550.
23	RANADE I S， FREDERICK R A. Experimental study of swirl coaxial injector hydrodynamics under high-frequency self-pulsation［C］∥ AIAA Propulsion and Energy 2019 Forum. Reston： AIAA， 2019.
24	EBERHART C， LINEBERRY D， FREDERICK R. Propellant throttling effects on self-pulsation of liquid rocket swirl-coaxial injection［C］∥ 48th AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit. Reston： AIAA， 2012.
25	EBERHART C J， LINEBERRY D M， FREDERICK JR R A. Detailing the stability boundary of self-pulsations for a swirl-coaxial injector element： AIAA-2013-4064 ［R］. Reston： AIAA， 2013.
26	FU Q F， YANG L J. Theoretical investigation of the dynamics of a gas-liquid coaxial swirl injector［J］. Journal of Propulsion and Power， 2011， 27（1）： 144-150.
27	康忠涛，张新桥，成鹏，等. 气核尺寸对气液同轴离心式喷嘴自激振荡的影响［J］. 航空学报， 2014， 35（12）： 3283-3292.
	KANG Z T， ZHANG X Q， CHENG P， et al. Influence of gas core dimension on self-pulsation of gas-liquid swirl coaxial injector［J］. Acta Aeronautica et Astronautica Sinica， 2014， 35（12）： 3283-3292 （in Chinese）.
28	EBERHART C J， FREDERICK R A. Fluid oscillations of a swirl coaxial injector under high-frequency self-pulsation［J］. Journal of Propulsion and Power， 2017， 33（4）： 804-814.
29	EBERHART C J. Investigation of liquid rocket swirl coaxial injection dynamics under self-excited high frequency ［D］. Huntsville： The University of Alabama in Huntsville， 2016.
30	EBERHART C J， FREDERICK R A. Parametric evaluation of swirl injector dynamics in the high-frequency range［J］. Journal of Propulsion and Power， 2017， 33（5）： 1218-1229.
31	EBERHART C J， FREDERICK R A. Details on the mechanism of high-frequency swirl coaxial self-pulsation［J］. Journal of Propulsion and Power， 2017， 33（6）： 1418-1427.
32	BAI X， CAO P J， LI Q L， et al. The break phenomenon of self-pulsation for liquid-centered swirl coaxial injectors［J］. International Journal of Multiphase Flow， 2021， 142： 103708.
33	薛帅杰，刘红军，洪流，等. 厚液膜敞口型离心喷嘴自激振荡特性试验［J］. 航空学报， 2018， 39（9）： 122198.
	XUE S J， LIU H J， HONG L， et al. Test on self-excited oscillation characteristics of an open-end swirl injector with thick liquid film［J］. Acta Aeronautica et Astronautica Sinica， 2018， 39（9）： 122198 （in Chinese）.
34	薛帅杰，刘红军，洪流，等. 厚液膜敞口型离心喷嘴动力学特性试验［J］. 航空学报， 2018， 39（12）： 122534.
	XUE S J， LIU H J， HONG L， et al. Experimental on dynamic characteristics of an open-end swirl injector with thick liquid film［J］. Acta Aeronautica et Astronautica Sinica， 2018， 39（12）： 122534 （in Chinese）.

Parameter	Value
D_c/mm	4.7
L_c/mm	40.05
D_k/mm	10.2
L_k/mm	10.2
D_t/mm	2
R_sw/mm	4
α/（°）	90
θ_t/（°）	10
L_r/mm	5
W_a/mm	0.5
T_w/mm	1.2

[1]	BAO Jun, WANG Yu, NIU Qian, ZHU Xidong, CHENG Jianjie. Influencing parameters and film flow mechanism of spray droplet impacting liquid film [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2021, 42(S1): 726360-726360.
[2]	GUAN Yu, CHEN Liang, CAO Qikai. Aircraft life extension based on incremental assessment: Method and application [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2021, 42(8): 525782-525782.
[3]	SHEN Lixin, XING Fei, QIN La, SU Hao. Numerical study on primary breakup characteristics of dual-layer rotating conical liquid sheets [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2021, 42(12): 625267-625267.
[4]	LIU Jiyu, ZHANG Fan, CHEN Yang, JIN Zhuji, LIU Xin. Low-temperature plasma assisted machining: A review [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2021, 42(10): 524754-524754.
[5]	WANG Kai, LEI Fanpei, YANG Anlong, YANG Baoe, ZHOU Lixin. Numerical simulation of spray and mixing process of impingement between sheet and jet in pintle injector element [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(9): 123802-123802.
[6]	KAN Ping, JIANG Zhaoliang, LIU Yuhao, WANG Zhenwu. Cooperative path planning for multi-sprayer-UAVs [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(4): 323610-323610.
[7]	CHEN Suyu, JIANG Tao, CHANG Yu, HU Shouchao, LI Qiang, ZHANG Kouli. Hypersonic boundary layer transition over bodies with blunt nosetip [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(12): 124098-124098.
[8]	ZHANG Haibin, BAI Bofeng. Droplet dispersion of hollow cone spray in gaseous crossflow: Characteristics and influencing factors [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(11): 123927-123927.
[9]	WANG Kai, LEI Fanpei, ZHANG Botao, YANG Anlong, ZHOU Lixin. Analysis on spray angle model for pintle injector element [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2020, 41(10): 123622-123622.
[10]	XUE Shuaijie, LIU Hongjun, CHEN Pengfei, XIA Yizhi. Test on spray stability of swirl injector with gas injection [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2019, 40(7): 122697-122697.
[11]	MAO Yufeng, LI Yunze, WANG Jixiang. Effect of overheat degree on water spray atomization under flash boiling condition [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2018, 39(S1): 722184-722184.
[12]	XUE Shuaijie, LIU Hongjun, HONG Liu, CHEN Pengfei. Test on self-excited oscillation characteristics of an open-end swirl injector with thick liquid film [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2018, 39(9): 122189-122198.
[13]	KANG Zhongtao, WANG Zhenguo, LI Qinglian, CHENG Peng. Influence of pressure oscillation on self-pulsation of gas-liquid swirl coaxial injector [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2018, 39(6): 121988-121988.
[14]	YANG Chengfeng, GUO Zhaodian, DENG Wenjian. Characteristic of airplane wheel water spray and its effect on water ingestion of engine inlet [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2018, 39(2): 121453-121453.
[15]	LU Shaowei, FENG Chunlin, NIE Peng, WANG Xiaoqiang, XIONG Xuhai, LYU Wei. Fabrication of carbon nanotube Buckypaper by spray-vacuum filtration method and its strain and temperature sensing properties [J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2015, 36(9): 3187-3194.

Generation and transmission mechanisms of disturbance inside injector during self-pulsation

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 14

References 34

Related Articles 15

Recommended Articles

Metrics

Comments