不同压力环境下竖直平板表面自然对流散热实验
收稿日期: 2015-06-15
修回日期: 2015-09-28
网络出版日期: 2015-09-30
基金资助
国家自然科学基金(51506009);可靠性与环境工程技术重点实验室开放基金(KHZS20143001)
Experiment on surface natural convection heat transfer of vertical plate under different pressures
Received date: 2015-06-15
Revised date: 2015-09-28
Online published: 2015-09-30
Supported by
National Natural Science Foundation of China (51506009);Open Foundation of China Science and Technology on Reliability and Environmental Engineering Laboratory (KHZS20143001)
飞行器从地面上升到太空的过程中所经历的大幅度环境参数变化,会导致飞行器及机载设备出现"超热"、"过冷"和"热分层"等现象。为得到不同环境压力下的关键参数——自然对流换热系数,本文搭建了一个能提供不同气压和环境温度的封闭试验舱,对在不同压力环境(0.0001,0.01,0.1,0.2,0.5,1,10,50 kPa和常压)下几种固定加热量(75,150,300 W/m2)的竖直平板散热进行了实验研究,通过对辐射散热和对流散热的分析比较,获取不用工况下气体的对流换热系数。结果表明:对流换热系数在绝对气压小于1 kPa时非常小,可以视作为0;在绝对气压大于1 kPa时,对流换热系数随压力的升高呈2次方增加;通过对环境物理参数的无因次化处理,得到的准则式方程可用于1~100 kPa的环境压力。
王晶 , 丁立 , 郄殿福 . 不同压力环境下竖直平板表面自然对流散热实验[J]. 航空学报, 2016 , 37(5) : 1506 -1511 . DOI: 10.7527/S1000-6893.2015.0252
When rising from the ground to space, aircraft will experience substantial changes in environmental parameters, which leads to the emergence of "super-hot", "super-cold" and "thermal stratification" phenomenon of aircraft and airborne equipment. The objective of the present study is to obtain the key parameter-free convection heat transfer coefficient under different environmental pressures. In this study, experiments are carried out under different pressure conditions (0.0001, 0.01,0.1, 0.2, 0.5, 1, 10, 50 kPa and atmospheric pressure) and different constant heat input (75,150, 300 W/m2) to measure the heat transfer of vertical plate. Then convection heat transfer coefficient can be obtained under different conditions by comparing heat loss between radiation and convection. The results indicate that:convection heat transfer coefficient is pretty low when absolute pressure is less than 1 kPa, which can be regarded as zero; when the absolute atmosphere is higher than 1 kPa, square relation is found between increasing convection heat transfer coefficient and increasing pressure; by processing environmental parameters with dimensionless method, the obtained criterion equation can be used between 1 kPa and 100 kPa.
Key words： low pressure; vertical plate; natural convection; radiation; dimensionless
[1] 曲东才. 飞艇研制及发展[J]. 航空科学与技术, 2006(2):40-41. QU D C. Study and development of airship[J]. Aviation Science and Technology, 2006(2):40-41(in Chinese).
[2] YAO W, LU X C, WANG C, et al. A heat transient model for the thermal behavior prediction of stratospheric airships[J]. Applied Thermal Engineering, 2014, 70(1):380-387.
[3] XIONG J J, BAI J B, CHEN L. Simplified analytical model for predicting the temperature of balloon on high-altitude[J]. International Journal of Thermal Sciences, 2014, 76:82-89.
[4] DE F L, XIN L X, CHUANG S. Experimental investigation of transient thermal behavior of an airship under different solar radiation and airflow conditions[J]. Advances in Space Research, 2014, 53(5):862-869.
[5] 姚伟, 李勇, 王文隽, 等. 平流层飞艇热力学模型和上升过程仿真分析[J]. 宇航学报, 2007, 28(3):603-607. YAO W, LI Y, WANG W J, et al. Thermodynamic model and numerical simulation of a stratospheric airship take-off process[J]. Journal of Astronautics, 2007, 28(3):603-607(in Chinese).
[6] 方贤德, 王伟志, 李小建. 平流层飞艇热仿真初步探讨[J]. 航天返回与遥感, 2007, 28(2):5-9. FANG X D, WANG W Z, LI X J. A study of thermal simulation of stratospheric airships[J]. Spacecraft Recovery & Remote Sensing, 2007, 28(2):5-9(in Chinese).
[7] WANG Y, LIU Y X. Numerical simulation about thermal environment of solar energy airship in stratosphere[C]//2012 International Workshop on Information and Electronics Engineering. Oxford:Elsevier, 2012:1745-1749.
[8] DEVIENNE F M. Low density heat transfer[J]. Advances in Heat Transfer, 1965, 2:271-356.
[9] NELSON K E, BEVANS J T. Errors of the calorimetric method of total emittance measurement:NASA, SP-ZEEE[R]. Washington, D.C.:NASA, 1963.
[10] KYTE J R, MADDEN A J, PIRET E L. Natural-convection heat transfer at reduced pressure[J]. Chemical Engineering Progress, 1953, 49(12):653-662.
[11] HPSSEINI R, TAHERIAN H. Natural convection heat transfer from a vertical plate to air at very low prseeure[J]. Transactions of the Canadian Society for Mechanical Engineering, 2004, 28(2B):309-319.
[12] CHURCHILL S W, CHU H H S. Correlating equations for laminar and turbulent free convection from a vertical plate[J]. International Journal of Heat and Mass Transfer, 1975, 18:1323-1329.
[13] 胡松涛, 朱春, 王东, 等. 低气压条件下电加热器自然对流换热性能测试[J]. 暖通空调, 2006, 36(3):22-24. HU S T, ZHU C, WANG D, et al. Testing of natural convection heat transfer performance of electric heaters under lower air pressure[J]. Heating Ventilating & Air Conditioning, 2006, 36(3):22-24(in Chinese).
[14] MOFFAT R J. Describing the uncertainties in experimentalresults[J]. Experimental Thermal and Fluid Science, 1988, 1(1):3-17.ifferent solar radiation and airflow conditions[J]. Advances in Space Research, 2014, 53:862-869.
[5]Yao W, Li Yong, Wang W J, Zheng W. Thermodynamic Model and Numerical Simulation of a StratosphericAirship Take-off Process[J]. Journal of As-tronautics, 2007, 28(3):603-607. (in Chinese)
姚伟, 李勇,王文隽,郑威. 平流层飞艇热力学模型和上升过程仿真分析[J]. 宇航学报, 2007, 28(3):603-607.
[6]Fang X D, Wang W Z, Li X J. A Study of Thermal Sim-ulation of Stratospheric Airships[J]. Spacecraft Recovery & Remote Sensing, 2007, 28(2):5-9. (in Chinese)
方贤德,王伟志,李小建.平流层飞艇热仿真初步探讨[J]. 航天返回与遥感,2007, 28(2):5-9.
[7]Yiran W, Yunxia L. Numerical Simulation about Thermal Environment of Solar Energy Airship in Stratosphere[J]. Procedia Engineering, 2012, 29:1745-1749.
[8]Hartnett J P, Irivine T F, Devienne F M. Low density heat transfer[M], in “Advances in heat transfer”. 1965, 2:271-356.
[9]Nelson K E, Bevans J T. Errors of the calorimetric method of total emittance measurement. Measurement of thermal radiation properties of solids[R], NASA, SP-ZEEE, 1963, 31:55-65.
[10]Kyte J R, Madden A J, Piret E L. Natural-Convection heat transfer at reduced pressure[J]. Chemical engineer-ing progress, 1953, 49 (12):653-662.
[11]Hosseini Reza, TaherianHessam. Natural convection heat transfer from a vertical plate to air at very low prseeure[C]. Transactions of the canadian society for mechanical engineering, 2004, 28(2B), 309-319.
[12]Churchill S W, Chu H H S. Correlating equations for laminar and turbulent free convection from a vertical plate[J]. Int. J. Heat Mass Transfer, 1975, 18: 1323-1329.
[13]Hu S T, Zhu C, Wang D, Zhang C X. Testing of natural convection heat transfer performance of electric heaters under lower air pressure[J]. HVAC, 2006, 36(3):22-24.
胡松涛, 朱春, 王东, 张长兴. 低气压条件下电加热器自然对流换热性能测试[J]. 暖通空调, 2006, 36(3):22-24.
/
| 〈 |
|
〉 |
CJA