ACTA AERONAUTICAET ASTRONAUTICA SINICA >
Bending failure mechanisms and energy absorption design of CFRP C-frames for civil aircraft fuselage
Received date: 2025-11-04
Revised date: 2025-11-24
Accepted date: 2025-12-29
Online published: 2026-01-09
Supported by
National Natural Science Foundation of China(U2433203);Tianjin Applied Basic Research Multi-Input Fund Project(23JCYBJC00070);Fundamental Research Funds for the Central Universities(3122025084)
To address the issue of insufficient bending energy absorption in Carbon Fiber Reinforced Polymer (CFRP) C-frames for civil aircraft fuselages, this study reveals the failure mechanisms and energy dissipation characteristics through quasi-static four-point bending numerical simulations and experimental benchmarking. Furthermore, the titanium alloy local reinforcement design method is proposed based on the failure mode control. The results indicate that the bending failure of the CFRP C-frame originates from the coupling effect between upper flange buckling and web bulging, which induces high interlayer stress and initial delamination at the upper corner. Consequently, the load-bearing capacity plummets to 12% of the peak load after failure, significantly constraining energy absorption. Energy dissipation exhibits significant regional heterogeneity: the web acts as the core energy absorption zone (accounting for 50.2%), followed by the upper flange (24.1%), while the upper corner, serving as the failure initiation point, contributes only 13.8%. Among the titanium alloy local reinforcement strategies, the upper corner local reinforcement (UC configuration) yields optimal performance. By leveraging the plastic deformation of titanium alloy to effectively delay initial failure, this configuration achieves a 26.1% increase in total energy absorption and a 22.3% increase in specific energy absorption, with a structural weight increase of only 3.4%. The titanium alloy local reinforcement design achieves the best balance between lightweighting and crashworthiness, providing a theoretical basis and engineering guidance for the crashworthiness design of civil aircraft fuselage structures.
Haolei MOU , Qingyi ZHENG , Yiming ZHAO . Bending failure mechanisms and energy absorption design of CFRP C-frames for civil aircraft fuselage[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2026 , 47(16) : 433046 -433046 . DOI: 10.7527/S1000-6893.2025.33046
| [1] | MOU H L, XIE J, FENG Z Y, et al. Review on the crashworthiness design and evaluation of fuselage structure for occupant survivability[J]. Progress in Aerospace Sciences, 2024, 148: 101001. |
| [2] | MOU H L, XIE J, FENG Z Y. Research status and future development of crashworthiness of civil aircraft fuselage structures: An overview[J]. Progress in Aerospace Sciences, 2020, 119: 100644. |
| [3] | 牟浩蕾, 解江, 冯振宇. 民机机身结构适坠性研究[J]. 交通运输工程学报, 2020, 20(3): 17-39. |
| MOU H L, XIE J, FENG Z Y. Research on crashworthiness of civil aircraft fuselage structures[J]. Journal of Traffic and Transportation Engineering, 2020, 20(3): 17-39 (in Chinese). | |
| [4] | WILLIAMS M S, HAYDUK R J. Vertical drop test of a transport fuselage section located forward of the wing: NASA-TM-84212[R]. Washington, D.C.: NASA, 1983. |
| [5] | WILLIAMS M S, HAYDUK R J. Vertical drop test of a transport fuselage center section including the wheel wells: NASA TM-85706[R]. Washington, D. C.: NASA, 1983. |
| [6] | ABRAMOWITZ A, SMITH T G, VU T. Vertical drop test of a narrow-body transport fuselage section with a conformable auxiliary fuel tank onboard: DOT/FAA/AR-00/56[R]. Washington, D.C.: FAA, 2000. |
| [7] | JACKSON K E, FASANELLA E L. Crash simulation of vertical drop tests of two boeing 737 fuselage sections: DOT/FAA/AR-02/62[R]. Washington, D. C.: FAA, 2002. |
| [8] | KUMAKURA I, MINEGISHI M, IWASAKI K, et al. Vertical drop test of a transport fuselage section[C]∥SAE Technical Paper Series. Warrendale: SAE International, 2002. |
| [9] | KUMAKURA I, MINEGISHI M, IWASAKI K, et al. Summary of vertical drop tests of YS-11 transport fuselage sections[C]∥SAE Technical Paper Series. Warrendale: SAE International, 2003. |
| [10] | LE PAGE F, CARCIENTA R. A320 fuselage section vertical drop test, Part 2: Test result: CEAT S95 5776/2[R]. Toulouse: CEAT, 1995. |
| [11] | GRANSDEN D I, ALDERLIESTEN R. Development of a finite element model for comparing metal and composite fuselage section drop testing[J]. International Journal of Crashworthiness, 2017, 22(4): 401-414. |
| [12] | CLIMENT H, AERONáUTICAS C. Non-linear response of metallic and composite aeronautical fuselage structures under crash loads and comparison with full scale test[C]∥European Congress on Computational Methods in Applied Sciences and Engineering. Athens: National Technical University of Athens, 2000. |
| [13] | LIU X C, GUO J, BAI C Y, et al. Drop test and crash simulation of a civil airplane fuselage section[J]. Chinese Journal of Aeronautics, 2015, 28(2): 447-456. |
| [14] | MOU H L, FENG Z Y, XIE J, et al. Collapse mechanism and occupant injury analysis under vertical impact of the aircraft fuselage structure[J]. Nonlinear Dynamics, 2025, 113(2): 1083-1105. |
| [15] | 牟浩蕾, 谢威威, 解江, 等. 坠撞环境下乘员伤害分析及飞机适坠性评估[J]. 航空学报, 2024, 45(3): 228786. |
| MOU H L, XIE W W, XIE J, et al. Occupant injury analysis and aircraft crashworthiness evaluation under crash scenarios[J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(3): 228786 (in Chinese). | |
| [16] | 惠旭龙, 刘小川, 白春玉, 等. 民机机身框段和全机坠撞响应对比[J]. 航空学报, 2025, 46(15): 231597. |
| XI X L, LIU X C, BAI C Y, et al. Comparison of crash response between fuselage section and full-scale civil aircraft[J]. Acta Aeronautica et Astronautica Sinica, 2025, 46(15): 231597 (in Chinese). | |
| [17] | 刘小川, 惠旭龙, 张欣玥, 等. 典型民用飞机全机坠撞实验研究[J]. 航空学报, 2024, 45(5): 529664. |
| LIU X C, XI X L, ZHANG X Y, et al. Full-scale crash experimental study of typical civil aircraft[J]. Acta Aeronautica et Astronautica Sinica, 2024, 45(5): 529664 (in Chinese). | |
| [18] | 牟浩蕾, 解江, 冯振宇, 等. 大型运输类飞机典型机身框段坠撞特性分析[J]. 航空学报, 2023, 44(9): 227512. |
| MOU H L, XIE J, FENG Z Y, et al. Crashworthiness characteristics analysis of typical fuselage section of large transport aircraft[J]. Acta Aeronautica et Astronautica Sinica, 2023, 44(9): 227512 (in Chinese). | |
| [19] | MOSTAFA R. Virtual test & simulation[C]∥Engineering, Operations & Technology. 2013: 1-24. |
| [20] | DI PALMA L, DI CAPRIO F, CHIARIELLO A, et al. Vertical drop test of composite fuselage section of a regional aircraft[J]. AIAA Journal, 2020, 58(1): 474-487. |
| [21] | RICCIO A, SAPUTO S, SELLITTO A, et al. An insight on the crashworthiness behavior of a full-scale composite fuselage section at different impact angles[J]. Aerospace, 2019, 72(6): 1-14. |
| [22] | SCHATROW P, WAIMER M. Crash concept for composite transport aircraft using mainly tensile and compressive absorption mechanisms[J]. CEAS Aeronautical Journal, 2016, 7(3): 471-482. |
| [23] | GUIDA M, MARULO F, ABRATE S. Advances in crash dynamics for aircraft safety[J]. Progress in Aerospace Sciences, 2018, 98: 106-123. |
| [24] | WAIMER M, FESER T, SCHATROW P, et al. Crash concepts for CFRP transport aircraft-comparison of the traditional bend frame concept versus the developments in a tension absorbers concept[J]. International Journal of Crashworthiness, 2018, 23(2): 193-218. |
| [25] | WAIMER M. Development of a kinematics model for the assessment of global crash scenarios of a composite transport aircraft fuselage[D]. Stuttgart: University of Stuttgart, 2013. |
| [26] | ROZYLO P. Limit states of thin-walled composite structures with closed sections under axial compression[J]. Composites Part B: Engineering, 2024, 287: 111813. |
| [27] | HEIMBS S, HOFFMANN M, WAIMER M, et al. Dynamic testing and modelling of composite fuselage frames and fasteners for aircraft crash simulations[J]. International Journal of Crashworthiness, 2013, 18(4): 406-422. |
| [28] | LIU X C, JIANG H Y, REN Y R, et al. Effects of global and local ply-reinforcements of critical components on crush performances of 2D tri-axially braided CFRP J-shaped fuselage frame[J]. International Journal of Crashworthiness, 2022, 27(3): 759-771. |
| [29] | MOU H L, ZHAO Y M, FENG Z Y. Comparative analysis of the bending crashworthiness of CFRP, metal and CFRP/metal hybrid C-frames[J]. Aerospace Science and Technology, 2025, 165: 110551. |
| [30] | WAIMER M, KOHLGRüBER D, KECK R, et al. Contribution to an improved crash design for a composite transport aircraft fuselage: Development of a kinematics model and an experimental component test setup[J]. CEAS Aeronautical Journal, 2013, 4(3): 265-275. |
| [31] | STURM R, HEIECK F. Energy absorption capacity of braided frames under bending loads[J]. Composite Structures, 2015, 134: 957-965. |
| [32] | 高宾华, 任毅如. 编织复合材料机身隔框的冲击动力学特性[J]. 复合材料学报, 2017, 34(8): 1780-1787. |
| GAO B H, REN Y R. Impact dynamic characteristics of braided composite fuselage frame[J]. Acta Materiae Compositae Sinica, 2017, 34(8): 1780-1787 (in Chinese). | |
| [33] | MOU H L, SU X, XIE J, et al. Parametric analysis of composite sinusoidal specimens under quasi-static crushing[J]. The Aeronautical Journal, 2018, 122(1254): 1244-1262. |
| [34] | ROZYLO P, DEBSKI H. Failure study of compressed thin-walled composite columns with top-hat cross-section[J]. Thin-Walled Structures, 2022, 180: 109869. |
| [35] | MOU H L, CHEN Y S, XIE J, et al. Crashworthiness analysis of single CFRP, hybrid CFRP/Al and fiber metal laminate C-channels: Quasi-static crushing tests and numerical simulations[J]. Thin-Walled Structures, 2025, 213: 113226. |
| [36] | HEIMBS S, HELLER S, MIDDENDORF P, et al. Low velocity impact on CFRP plates with compressive preload: Test and modelling[J]. International Journal of Impact Engineering, 2009, 36(10-11): 1182-1193. |
| [37] | 惠旭龙, 牟让科, 白春玉, 等. TC4钛合金动态力学性能及本构模型研究[J]. 振动与冲击, 2016, 35(22): 161-168. |
| XI X L, MU R K, BAI C Y, et al. Dynamic mechanical property and constitutive model for TC4 titanium alloy[J]. Journal of Vibration and Shock, 2016, 35(22): 161-168 (in Chinese). |
/
| 〈 |
|
〉 |