Fluid Mechanics and Flight Mechanics

High-precision modeling and simulation of distributed propulsion energy systems for eVTOL/eSTOL

  • Sanya SUN ,
  • Zhuang SHAO ,
  • Zhou ZHOU ,
  • Kelei WANG ,
  • Jia ZONG
Expand
  • 1.School of Aeronautics,Northwestern Polytechnical University,Xi’an 710072,China
    2.National Key Laboratory of Aircraft Configuration Design,Xi’an 710072,China

Received date: 2024-11-11

  Revised date: 2024-12-18

  Accepted date: 2025-02-03

  Online published: 2025-02-10

Supported by

Basic Research Project for Featured Disciplines of China(G2022WD);Aeronautical Science Foundation of China(2024Z006053001)

Abstract

Addressing the challenges posed by drastic power load variations and high losses in complex transmission systems for distributed electric propulsion aircraft such as electric Vertical Take-Off and Landing/ electric Short Take-Off and Landing(eVTOL/eSTOL), this paper proposes a high-precision power and energy system modeling and evaluation method applicable to the entire flight process of unmanned aerial vehicles (UAVs). We first establish an energy system model based on a second-order RC battery model, identifying key parameters through a particle swarm algorithm using battery discharge experimental data, and construct a propulsion system model including propellers, motors, Electronic Speed Controllers (ESCs), and transmission cables. Subsequently, a working state calculation framework for the UAV power and energy system based on an implicit function equation system is introduced and validated against experimental data. Finally, a simulation assessment of the power and energy system is conducted for a specific project involving a distributed electric propulsion UAV, alongside the optimization design of the transmission cable layout. The results indicate that both the voltage prediction error of the energy system and the errors in the system state calculation framework are smaller than 2%. The model accurately reflects the operational state changes of each component throughout the entire flight process, and the optimized transmission cable layout reduces voltage loss by 17.2% and average power loss by 16.36%, thereby verifying the accuracy and validity of the proposed method.

Cite this article

Sanya SUN , Zhuang SHAO , Zhou ZHOU , Kelei WANG , Jia ZONG . High-precision modeling and simulation of distributed propulsion energy systems for eVTOL/eSTOL[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2025 , 46(15) : 131513 -131513 . DOI: 10.7527/S1000-6893.2025.31513

References

[1] ZAID A ABU, BELMEKKI B E Y, ALOUINI M S. eVTOL communications and networking in UAM: requirements, key enablers, and challenges[J]. IEEE Communications Magazine202361(8): 154-160.
[2] ZHAO W, WANG Y Q, LI L Q, et al. Design and flight simulation verification of the dragonfly eVTOL aircraft[J]. Drones20248(7): 311.
[3] 邓景辉. 电动垂直起降飞行器的技术现状与发展[J]. 航空学报202445(5): 55-77.
  DENG J H. Technical status and development of electric vertical take-off and landing aircraft[J]. Acta Aeronautica et Astronautica Sinica202445(5): 55-77 (in Chinese).
[4] SHAHJAHAN S, GONG A, MOORE A, et al. Optimisation of proprotors for tilt-wing eVTOL aircraft?[J]. Aerospace Science and Technology2024144: 108835.
[5] DIXIT M, BISHT A, WITHERSPOON B, et al. Battery electrolyte design for electric vertical takeoff and landing (eVTOL) platforms[J]. Advanced Energy Materials202414(29): 2400772.
[6] 王科雷, 周洲, 郭佳豪, 等. 分布式动力翼前飞状态动力/气动耦合特性[J]. 航空学报202445(2):137-155.
  WANG K L, ZHOU Z, GUOJIA H, et al. Propulsive/aerodynamic coupled characteristics of distributed-propulsion-wing during forward flight[J]. Acta Aeronautica et Astronautica Sinica202445(2): 137-155 (in Chinese).
[7] PARK J, LEE D, LIM D, et al. A refined sizing method of fuel cell-battery hybrid system for eVTOL aircraft[J]. Applied Energy2022328: 120160.
[8] 于昊亮, 雷涛, 张星雨, 等. 一种分布式电推进飞机的多学科参数快速估计方法[J]. 航空科学技术202435(1): 65-74.
  YU H L, LEI T, ZHANG X Y, et al. A fast multidisciplinary parameter estimation method for distributed electric propulsion aircraft[J]. Aeronautical Science & Technology202435(1): 65-74 (in Chinese).
[9] WANG M, DIEPOLDER J, ZHANG S, et al. Trajectory optimization-based maneuverability assessment of eVTOL aircraft[J]. Aerospace Science and Technology2021117: 106903.
[10] TEKIN M, KARAMANGIL M ?. Comparative analysis of equivalent circuit battery models for electric vehicle battery management systems[J]. Journal of Energy Storage202486: 111327.
[11] 彭纪昌, 刘凯龙, 孟锦豪, 等. 基于变参数结构的锂离子电池建模方法[J]. 机械工程学报202460(14): 298-305.
  PENG J C, LIU K L, MENG J H, et al. Dynamically parameterized structure for lithium-ion battery method[J]. Journal of Mechanical Engineering202460(14): 298-305 (in Chinese).
[12] 龙潘, 耿光超, 江全元, 等. 储能系统锂电池电热耦合建模及参数辨识方法研究[J]. 太阳能学报202445(4): 318-327.
  LONG P, GENG G C, JIANG Q Y, et al. Study on electrothermal coupling modeling and parameter identification of lithium battery energy storage system[J]. Acta Energiae Solaris Sinica202445(4): 318-327 (in Chinese).
[13] GARCíA-RODRíGUEZ V H, SILVA-ORTIGOZA R, HERNáNDEZ-MáRQUEZ E, et al. DC/DC boost converter-inverter as driver for a DC motor: Modeling and experimental verification?[J]. Energies201811(8): 2044.
[14] 吴雨林, 李众. 无刷直流电机的分数阶建模方法[J]. 计算机与数字工程202250(2): 453-457.
  WU Y L, LI Z. Method of fractional order modeling for BLDCM[J]. Computer & Digital Engineering202250(2): 453-457 (in Chinese).
[15] SHI D J, DAI X H, ZHANG X W, et al. A practical performance evaluation method for electric multicopters[J]. IEEE/ASME Transactions on Mechatronics201722(3): 1337-1348.
[16] 雷涛, 孔德林, 王润龙, 等. 分布式电推进飞机动力系统评估优化方法[J]. 航空学报202142(6): 44-63.
  LEI T, KONG D L, WANG R L, et al. Evaluation and optimization method for power systems of distributed electric propulsion aircraft[J]. Acta Aeronautica et Astronautica Sinica202142(6): 44-63 (in Chinese).
[17] WANG M K, ZHANG S G, JOHANNES D, et al. Battery package design optimization for small electric aircraft[J]. Chinese Journal of Aeronautics202033(11): 2864-2876.
[18] 张茂权, 陈海昕. 小型电动无人机航程航时估算模型[J]. 航空学报202142(3): 104-112.
  ZHANG M Q, CHEN H X. Estimated model of range and endurance of small electric UAVs[J]. Acta Aeronautica et Astronautica Sinica202142(3): 104-112 (in Chinese).
[19] 邓涛, 谭溪, 熊志豪, 等. 垂直起降固定翼无人机混合电推进系统设计与仿真研究[J]. 重庆交通大学学报(自然科学版)202342(10): 156-162.
  DENG T, TAN X, XIONG Z H, et al. Design and simulation of hybrid electric propulsion system for convertiplane?[J]. Journal of Chongqing Jiaotong University (Natural Science)202342(10): 156-162 (in Chinese).
[20] GRANADO L, BEN-MARZOUK M, SOLANO SAENZ E, et al. Machine learning predictions of lithium-ion battery state-of-health for eVTOL applications?[J]. Journal of Power Sources2022548: 232051.
[21] 岳永胜, 孙冬, 许爽, 等. 锂离子电池等效电路模型的研究进展[J]. 电池202353(6): 682-686.
  YUE Y S, SUN D, XU S, et al. Research progress in equivalent circuit model for Li-ion battery[J]. Battery Bimonthly202353(6): 682-686 (in Chinese).
[22] TOMASOV M, KAJANOVA M, BRACINIK P, et al. Overview of battery models for sustainable power and transport applications[J]. Transportation Research Procedia201940: 548-555.
[23] LI M T, CAO Y, WANG C S, et al. Evaluation and analysis of circuit model for lithium batteries[C]∥2022 41st Chinese Control Conference (CCC). Piscataway: IEEE Press, 2022: 1343-1348.
[24] FULLER M E. A battery model for constant-power discharge including rate effects[J]. Energy Conversion and Management201488: 199-205.
[25] MOUSSA S, GHORBAL M J BEN. Shepherd battery model parametrization for battery emulation in EV charging application[C]∥2022 IEEE International Conference on Electrical Sciences and Technologies in Maghreb (CISTEM). Piscataway: IEEE Press, 2022: 1-6.
[26] FOTOUHI A, AUGER D J, PROPP K, et al. Lithium-sulfur battery state-of-charge observability analysis and estimation[J]. IEEE Transactions on Power Electronics201833(7): 5847-5859.
[27] NIKOLIAN A, DE HOOG J, FLEURBAEY K, et al. Classification of electric modeling and characterization methods of lithium-ion batteries for vehicle applications[C]∥Proceedings of the European Electric Vehicle Congress 2014 . Brussels: European Electric Vehicle Congress, 2014: 13-16.
[28] 代云腾, 彭乔, 刘天琪, 等. 适应高电流倍率工况的锂离子电池等效电路模型[J]. 储能科学与技术202312(11): 3528-3537.
  DAI Y T, PENG Q, LIU T Q, et al. Application of equivalent circuit model of lithium-ion batteries to high current rate condition?[J]. Energy Storage Science and Technology202312(11): 3528-3537 (in Chinese).
[29] 毛琦, 祝乔, 徐志杰, 等. 基于粒子群优化算法的锂电池模型参数辨识[J]. 电工技术2021(12): 156-157.
  MAO Q, ZHU Q, XU Z J, et al. Parameter identification of batter model based on the particle swarm optimization[J]. Electric Engineering2021(12): 156-157 (in Chinese).
[30] 刘沛清. 空气螺旋桨理论及其应用[M]. 北京: 北京航空航天大学出版社, 2006: 75-82.
  LIU P Q. Air propeller theory and its application[M]. Beijing: Beijing University of Aeronautics & Astronautics Press, 2006: 75-82 (in Chinese).
[31] BANGURA M, LIM H, KIM H J, et al. Aerodynamic power control for multirotor aerial vehicles?[C]∥2014 IEEE International Conference on Robotics and Automation (ICRA). Piscataway: IEEE Press, 2014: 529-536.
[32] LINDAHL P, MOOG E, SHAW S R. Simulation, design, and validation of an UAV SOFC propulsion system[J]. IEEE Transactions on Aerospace and Electronic Systems201248(3): 2582-2593.
[33] DAI X H, QUAN Q, REN J R, et al. An analytical design-optimization method for electric propulsion systems of multicopter UAVs with desired hovering endurance?[J]. IEEE/ASME Transactions on Mechatronics201924(1): 228-239.
[34] QIN J C, ZHOU Z, YANG G W, et al. Aero-propulsive coupling modeling and dynamic stability analysis of distributed electric propulsion tandem-wing UAV with rapid ascent capability?[J]. Aerospace Science and Technology2024153: 109406.
Outlines

/