流体力学与飞行力学

对转压气机最先失速级的小扰动理论分析

  • 高丽敏 ,
  • 李晓军 ,
  • 谢建 ,
  • 刘波
展开
  • 西北工业大学 动力与能源学院, 陕西 西安 710072
高丽敏 女, 博士, 教授。主要研究方向: 航空与民用叶轮机械复杂流场及气动性能的数值仿真及测量技术、 高效节能叶轮机械设计、 计算流体力学理论及其在复杂结构中工程应用、 流动显示技术等。 Tel: 029-88495022 E-mail: gaolm@nwpu.edu.cn

收稿日期: 2012-03-05

  修回日期: 2012-11-28

  网络出版日期: 2013-03-29

Prediction of Onset of Rotating Stall Using Small Perturbation Theory for Contra-rotating Compressors

  • GAO Limin ,
  • LI Xiaojun ,
  • XIE Jian ,
  • LIU Bo
Expand
  • School of Power and Energy, Northwestern Polytechnical University, Xi'an 710072, China

Received date: 2012-03-05

  Revised date: 2012-11-28

  Online published: 2013-03-29

摘要

对转压气机(CRC)由于其独特的气动和结构优势而被认为是进一步提高航空发动机推重比的重要技术途径之一。在小扰动理论的基础上发展了对转压气机旋转失速的小扰动分析方法,并以实验室对转压气机为研究对象,采用小扰动理论和计算流体力学(CFD)数值模拟两种方法对不同转速匹配工况下的最先失速级位置进行了相应的研究,为对转压气机失速边界的预估探索一种快速有效的方法。研究结果表明:①旋转失速的小扰动分析方法可以较好地预估对转压气机失速边界和最先失速级位置;②小扰动分析方法和CFD计算结果均显示:转速匹配方案对对转压气机最先失速级位置存在明显的影响。当转速比大于或等于0.9时,转子2为最先失速级;当转速比小于0.9时,转子1为最先失速级;③由于小扰动分析方法进行了大量的简化,因而使得预估值同实际值之间存在相应的误差。同时,由于对转压气机级间存在较强的非定常性,进而使得相对误差进一步增大。

本文引用格式

高丽敏 , 李晓军 , 谢建 , 刘波 . 对转压气机最先失速级的小扰动理论分析[J]. 航空学报, 2013 , 34(3) : 533 -540 . DOI: 10.7527/S1000-6893.2013.0089

Abstract

With its structural and aerodynamic advantages, the contra-rotating compressor (CRC) is considered an important approach to further improve the thrust-weight ratio of an aircraft engine. The configuration studied in this paper is a dual-stage contra-rotating compressor in laboratory, and the onset of rotating stall of the contra-rotating compressor in different rotating speed match schemes is studied with small perturbation theory and computational fluid dynamics (CFD) numerical method. The purpose of this study is to explore a fast and efficient method for prediction of the onset of rotating stall for contra-rotating compressor. Results show: (a) the small perturbation theory is a reliable and effective method for the prediction of the onset of rotating stall. At the condition of rotating speed ratio is less than or equal to 0.9, Rotor 2 is the first stall stage. Otherwise, Rotor 1 is the first stall stage; (b) the rotating speed match scheme has a significant impact on the location of the first rotating stall stage; (c) the errors of the small perturbation method arise mainly from the simplification of the flow models, and the strong disturbance between the two rotors of the contra-rotating compressor enlarges the errors.

参考文献

[1] Sharma P B, Jain Y P, Pundir D S. A study of some factors affecting the performance of a contra-rotating axial compressor stage. Proceedings of the Institution of Mechanical Engineers, Part A: Journal of Power and Energy, 1988, 202(1): 15-21.

[2] Sharma P B, Pundir D S. A study of flow structure in a contra-rotating axial compressor stage. ISABE 89-7023, 1989: 237-244.

[3] Pundhir D S, Sharma P B. A study of aerodynamic performance of a contra-rotating axial compressor stage. Defence Science Journal, 1992, 42(3): 191-199.

[4] Sharma P B, Jain Y P. Stall behavior of a contra-rotating axial compressor stages. ISABE 85-7087, 1985.

[5] Sharma P B. Surge and stall studies in an axial compressor. Annual Project Report 1987-88, 1988.

[6] Freedman J H. Design of a multi-spool, high-speed, contra-rotating, aspirated compressor. Massachusetts: Master of Science, Massachusetts Institute of Technology, 2002.

[7] Kirchner J. Aerodynamic design of an aspirated contra-rotating compressor. Massachusetts: Master of Science, Massachusetts Institute of Technology, 2002.

[8] Knapke R D, Turner M G, List M G, et al. Time accurate simulations of a counter-rotating aspirated compressor. ASME Paper, GT-2008-50877, 2008.

[9] Guidotti E, Turner M G. Analysis of unsteady flow in an aspirated counter-rotating compressor using the nonlinear harmonic method. ASME Paper, GT-2009-60285, 2009.

[10] Liang X Z, Wu H, Zhao Z. Design and experimental investigation of contra rotating axial flow fan. Journal of China Coal Society, 1999, 24(1): 94-97.(in Chinese) 梁锡智, 吴海, 赵真. 轴流对旋风机的设计和试验研究. 煤炭学报, 1999, 24(1): 94-97.

[11] Wang J, Song W Y. Investigation on comparison of power characteristics for two-stage counter-rotating axial flow fans. Fluid Machinery, 2000, 28(11): 5-7. (in Chinese) 王军, 宋文艳. 对旋风机两级功率特性的对比研究. 流体机械, 2000, 28(11): 5-7.

[12] Wang J, Wang J F, Tang D Y. Numerical simulation of internal flow of contra-rotating axial flow fan. Journal of Northwestern Polytechnical University, 2000, 18(4): 583-586.(in Chinese) 王军, 王建峰, 唐狄毅. 对转式轴流风机内流的数值模拟. 西北工业大学报, 2000,18(4): 583-586.

[13] Zhu W, Li Q S, Fan H T, et al. Experimental investigation on flow field between two fans of contra-rotating fan unit. Journal of Aerospace Power, 2001, 16(2): 158-162. (in Chinese) 朱巍, 李秋实, 范洪涛, 等. 对旋风机对旋叶轮级间流场的试验研究. 航空动力学报, 2001, 16(2): 158-162.

[14] Wang Y G, Liu B, Chen Y Y, et al. Flow field investigation of dual stage counter-rotating compressor. Journal of Northwestern Polytechnical University, 2006, 24(1): 97-101. (in Chinese) 王掩刚, 刘波, 陈云永, 等. 双级对转压气机流场分析研究. 西北工业大学学报, 2006, 24(1): 97-101.

[15] Liu B, Chen Y Y, Xiang X R. Experimental and numerical investigation of dual stage counter-rotating compressor. Journal of Propulsion Technology, 2008, 29(4): 454-457. (in Chinese) 刘波, 陈云永, 项效镕, 等. 对转压气机数值模拟及试验研究. 推进技术, 2008, 29(4): 454-457.

[16] Wang Y G, Jia R Q, Niu N. Numerical investigation of dual stage counter-rotating compressor for on-design or off-design conditions. Journal of Northwestern Polytechnical University, 2008, 26(5): 535-539. (in Chinese) 王掩刚, 贾瑞琦, 牛楠, 等. 双级对转压气机多工况数值分析研究. 西北工业大学学报, 2008, 26(5): 535-539.

[17] Gao L M, Bai Y, Han W, et, al. Influence of inlet guide vane adjustment on performance of dual-stage counter rotating compressor. Journal of Engineering Thermophysics, 2010, 31(4): 573-576. (in Chinese) 高丽敏, 白莹, 韩伟, 等. 导叶调节对双级对转压气机性能影响的研究. 工程热物理学报, 2010, 31(4): 573-576.

[18] Ludwing G R, Nenni J P, Arendt R H. Investigation of rotating stall in axial compressors and the development of a proto-type stall control system. AFAPL-TR-73-45, 1973.

[19] Liu Z W. Prediction of onset of rotating stall using small perturbation theory for axial flow compressors. Journal of Engineering Thermophysics, 1981, 2(3): 230-236. (in Chinese) 刘志伟. 小扰动理论预估轴流压气机旋转失速起始点的研究.工程热物理学报, 1981, 2(3): 230-236.

[20] Zhu J Q, Liu Z W. Research of onset of rotating stall for double blade rows. Journal of Engineering Thermophysics, 1988, 9(3): 218-223. (in Chinese) 朱俊强, 刘志伟. 双叶排旋转失速起始的研究. 工程热物理学报, 1988, 9(3): 218-223.

文章导航

/