任务期间考虑故障件报废无补给下的多级装备可用度评估

doi:10.7527/S1000-6893.2016.0268

固体力学与飞行器总体设计

本期目录 | 过刊浏览 | 高级检索

前一篇 | 后一篇

任务期间考虑故障件报废无补给下的多级装备可用度评估

刘任洋¹, 李华², 李庆民³

1. 海军装备研究院, 北京 100037;
2. 海军工程大学兵器工程系, 武汉 430033;
3. 海军工程大学科研部, 武汉 430033

收稿日期:2016-05-24 修回日期:2016-10-08 出版日期:2017-04-15 发布日期:2016-10-14
通讯作者: 李庆民 E-mail:licheng001@hotmail.com
基金资助:
国防预研项目基金（51304010206，51327020105）

Evaluation for availability of multi-echelon multi-indenture equipment with scrap of failure parts during the mission

LIU Renyang¹, LI Hua², LI Qingmin³

1. Naval Academy of Armament, Beijing 100037, China;
2. Department of Weaponry Engineering, Naval University of Engineering, Wuhan 430033, China;
3. Office of Research & Development, Naval University of Engineering, Wuhan 430033, China

Received:2016-05-24 Revised:2016-10-08 Online:2017-04-15 Published:2016-10-14
Supported by:
National Defense Pre-research Foundation of China (51304010206, 51327020105)

摘要/Abstract

摘要：

针对任务期间普遍存在的故障件报废问题，提出了一种适用于多等级多层级航空装备的可用度近似评估方法。首先通过忽略维修和运输时间将存在报废率的可修件等效为消耗件，然后分别通过后方保障中心对飞行基地备件量的分配以及下层级部件对上层级部件备件量的折算，将多等级多层级备件模型转化为单等级单层级模型，最后利用伽马分布的可加性得到整个保障系统的装备可用度。在实际算例中，通过与仿真结果的对比得出：当维修和运输时间较小或飞行基地备件配置充足时，本文提出的近似评估方法具有较高的精度。

关键词: 任务期间, 多等级多层级, 故障件报废, 可用度, 备件方案

Abstract:

For the problem of scrap of failure parts existing widely during the mission, an approximate evaluation method for availability of multi-echelon multi-indenture aviation equipment is proposed. Repairable spares with scrap are converted to non-repairable spares by omitting repair and transportation time. The spares are then assigned from the rear support center to the flight base and are converted from lower in to higher indenture successively, so that the multi-echelon multi-indenture spare model is converted into the single-echelon single-indenture ones. The availability of the whole support system is obtained based on the additive property of Gamma distribution. A comparison of the actual example with the simulation results shows that the approximate algorithm can be of high precision when the values of repair and transportation time are not too great or the spares of the flight base are sufficient.

Key words: during the mission, multi-echelon multi-indenture, scrap of failure parts, availability, configuration plan of spare parts

中图分类号:

刘任洋, 李华, 李庆民. 任务期间考虑故障件报废无补给下的多级装备可用度评估[J]. 航空学报, 2017, 38(4): 220465-220465.

LIU Renyang, LI Hua, LI Qingmin. Evaluation for availability of multi-echelon multi-indenture equipment with scrap of failure parts during the mission[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2017, 38(4): 220465-220465.

参考文献

[1] SHERBROOKE C C. METRIC:A multi-echelon technique for recoverable item control[J]. Operations Research, 1968, 16(2):122-141.
[2] MUCKSTADT J. A model for a multi-item, multi-echelon, multi-indenture inventory system[J]. Management Science, 1973(20):472-481.
[3] SHERBROOKE C C. VARI-METRIC:Improved approximations for multi-indenture multi-echelon availability models[J]. Operations Research, 1986, 34(2):311-319.
[4] HILLESTAD R J. Dynametric:Dynamic multi-echelon technique for recoverable item control:R-2785-AF[R]. Santa Monica:RAND Corporation, 1982.
[5] FRANCESCO C, GIULIO D G, MASSIMO T. Multi-echelon, multi-indenture spare parts inventory control subject to system availability and budget constraints[J]. Reliability Engineering and System Safety, 2013, 119:95-101.
[6] SALMAN S, CASSADY C R, POHL E A, et al. Evaluating the impact of cannibalization on fleet performance[J]. Quality and Reliability Engineering International, 2007, 23(4):445-457.
[7] 李羚伟, 张建军, 张涛, 等. 面向任务的拼修策略问题及其求解算法[J]. 系统工程理论与实践, 2009, 29(7):97-104. LI L W, ZHANG J J, ZHANG T, et al. Mission oriented cannibalization policy problem and its solving algorithm[J]. Systems Engineering-Theory & Practice, 2009, 29(7):97-104 (in Chinese).
[8] 罗祎, 阮旻智, 李庆民. 多级维修供应下不完全串件系统可用度评估[J]. 系统工程与电子技术, 2012, 34(6):1182-1186. LUO Y, RUAN M Z, LI Q M. Evaluation of availability for incomplete cannibalization system under multi-echelon maintenance supply[J]. Systems Engineering and Electronics, 2012, 34(6):1182-1186 (in Chinese).
[9] OLSSON F. An inventory model with unidirectional lateral transshipments[J]. European Journal of Operations Research, 2010, 200(3):725-732.
[10] LORENZO T, STEFANO S. Reducing the mean supply delay of spare parts using lateral transshipments policies[J]. International Journal of Production Economics, 2011, 133(1):182-191.
[11] 张光宇, 李庆民, 李华. 零备件的多点库存单向转运模型与算法[J]. 航空学报, 2013, 34(5):1092-1100. ZHANG G Y, LI Q M, LI H. Unidirectional transshipment model and algorithm in multi-location inventory of spare part[J]. Acta Aeronautica et Astronautica Sinica, 2013, 34(5):1092-1100 (in Chinese).
[12] 刘任洋, 李庆民, 李华. 基于横向转运策略的可修件三级库存优化模型[J]. 航空学报, 2014, 35(12):3341-3349. LIU R Y, LI Q M, LI H. Optimal model of three-echelon inventory for repairable spare parts with lateral transshipments[J]. Acta Aeronautica et Astronautica Sinica, 2014, 35(12):3341-3349 (in Chinese).
[13] LAU H C, SONG H W, SEE C T, et al. Evaluation of time-varying availability in multi-echelon spare parts systems with passivation[J]. European Journal of Operational Research, 2005, 170(1):91-105.
[14] 王睿, 彭英武, 李庆民, 等. 面向动态任务的作战单元两等级两层级可修复备件优化[J]. 系统工程与电子技术, 2013, 35(4):761-769. WANG R, PENG Y W, LI Q M, et al. Dynamic mission-oriented two-echelon and two-indenture repairable spare parts optimization for combat units[J]. System Engineering and Electronics, 2013, 35(4):761-769 (in Chinese).
[15] RUAN M Z, LUO Y, LI H. Configuration model of partial repairable spares under batching ordering policy on inventory state[J]. Chinese Journal of Aeronautics, 2014, 27(3):558-567.
[16] 甘茂治, 康建设, 高崎. 军用装备维修工程学[M]. 2版. 北京:国防工业出版社, 2010:44-46. GAN M Z, KANG J S, GAO Q. Military equipment maintenance engineering[M]. 2nd ed. Beijing:National Defense Industry Press, 2010:44-46 (in Chinese).
[17] SHERBROOKE C C. Optimal inventory modeling of system:Multi-echelon techniques[M]. 2nd ed. Boston:Artech House, 2004:31-32.

E-mail：hkxb@buaa.edu.cn

关于我们

期刊社服务

专业学科

封面文章

友情链接

主管单位：中国科学技术协会主办单位：中国航空学会北京航空航天大学

任务期间考虑故障件报废无补给下的多级装备可用度评估

Evaluation for availability of multi-echelon multi-indenture equipment with scrap of failure parts during the mission

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 8

编辑推荐

Metrics

本文评价

[1]	黎放, 何有宸, 狄鹏, 陈童, 尹东亮. 考虑维修力量影响及载荷动态分配的k/n系统模糊可靠性分析[J]. 航空学报, 2018, 39(4): 221718-221718.
[2]	邵松世, 张志华, 李华, 刘任洋. 正态型有寿件的备件方案确定方法[J]. 航空学报, 2018, 39(1): 221147-221147.
[3]	刘任洋, 李庆民, 李华, 熊宏锦. 多指标约束下考虑报废的可修复备件携行方案优化[J]. 航空学报, 2016, 37(10): 3131-3139.
[4]	王蕴, 王乃超, 马麟, 李铁, 邓浩然. 考虑备件约束的多部件串联系统使用可用度计算方法[J]. 航空学报, 2015, 36(4): 1195-1201.
[5]	卢雷, 杨江平. k/N（G）结构系统初始备件配置方法[J]. 航空学报, 2014, 35(3): 773-779.
[6]	阮旻智, 李庆民, 彭英武, 黄傲林, 王慎. 串件拼修对策下多级维修供应的装备系统可用度评估[J]. 航空学报, 2012, (4): 658-665.
[7]	吕德峰;左洪福;蔡景. 基于功能检测的备用系统维修优化研究[J]. 航空学报, 2009, 30(4): 660-665.
[8]	杨懿;王立超;邹云. 考虑预防性维修的离散时间单部件系统的可用度模型[J]. 航空学报, 2009, 30(1): 68-72.