ACTA AERONAUTICAET ASTRONAUTICA SINICA >
Experimental investigation on structural vibration induced by fluid-acoustic-structure coupling and its suppression
Received date: 2023-12-12
Revised date: 2023-12-25
Accepted date: 2024-01-30
Online published: 2024-02-07
Supported by
National Natural Science Foundation of China(52276045)
Blade vibration caused by flow-induced acoustic resonance is a typical representative of non-synchronous vibration problems inside the compressor. Existing research focuses mostly on vortex-acoustic coupling in acoustic resonance， while less attention is paid to structural vibration issues caused by acoustic resonance. To study the complex fluid-acoustic-structure coupling phenomenon in acoustic resonance， this study carried out acoustic resonance experiments on an aluminum flat plate in a low-speed wind tunnel. Synchronized measurements were performed on the shedding vortex pulsation velocity at the trailing edge of the plate， the acoustic pressure inside the duct， and the plate vibration. The experimental results captured the phenomenon of frequency locking and amplitude jumps， and found that the amplitude of plate vibration caused by acoustic resonance can reach half of the flow-induced resonance amplitude， indicating that vibration induced by acoustic resonance needs to be taken seriously in industrial applications. Finally， the acoustic resonance suppression strategy based on the non-local acoustic liner on the wall was studied， achieving dual suppression of sound pressure within the duct and plate vibration.
Zhiliang HONG , Li XUE , Yilei FU , Lingfeng CHEN . Experimental investigation on structural vibration induced by fluid-acoustic-structure coupling and its suppression[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2024 , 45(19) : 229970 -229970 . DOI: 10.7527/S1000-6893.2024.29970
| 1 | SEMRAU S， SKODA R， WUSTMANN W， et al. Experimental and numerical investigation of noise generation due to acoustic resonance in a cavitating valve［J］. Journal of Sound and Vibration， 2019， 463： 114956. |
| 2 | SAMUEL G， ALEX K， BORIS L， et al. Experimental investigation of forced convection enhancement by acoustic resonance excitations in turbulated heat exchangers［J］. Journal of Turbomachinery， 2020， 142（2）： 021005. |
| 3 | HOLZINGER F， WARTZEK F， SCHIFFER H P， et al. Self-excited blade vibration experimentally investigated in transonic compressors： Acoustic resonance［J］. Journal of Turbomachinery， 2016， 138（4）： 041001. |
| 4 | BRANDSTETTER C， PAOLETTI B， OTTAVY X. Acoustic and convective mechanisms contributing to non-synchronous-vibrations in a multistage compressor［C］∥ASME Turbo Expo 2019： Turbomachinery Technical Conference and Exposition. New York： ASME， 2019： GT2019-91514. |
| 5 | 冯建文， 甄博. 普惠PW1500G发动机声疲劳事件分析［J］. 航空动力， 2023（1）： 72-74. |
| FENG J W， ZHEN B. Analysis to acoustic fatigue incidents of PW1500G engine［J］. Aerospace Power， 2023（1）： 72-74 （in Chinese）. | |
| 6 | ROBERT H. Aviation Investigation-4 Docket Items： ENG19IA029［R］. Washington， D. C．： NTSB， 2021. |
| 7 | PARKER R. An investigation of acoustic resonance effects in an axial flow compressor stage［J］. Journal of Sound and Vibration， 1968， 8： 281-297. |
| 8 | JU H B. Effects of vane sweep on fan-wake/outlet-guide-vane interaction broadband noise［C］∥22nd AIAA/CEAS Aeroacoustics Conference. Reston： AIAA， 2016：AIAA 2016-2948． |
| 9 | LISE F A， CHRISTOPH B， STéPHANE A， et al. Non-synchronous aeroacoustic interaction in an axial multi-stage compressor［J］. Journal of Turbomachinery， 2019， 141（10）：101013. |
| 10 | CAMP T R. A study of acoustic resonance in a low-speed multistage compressor［J］. Journal of Turbomachinery， 1999， 121（1）： 36-43. |
| 11 | HELLMICH B， SEUME J R. Causes of acoustic resonance in a high-speed axial compressor［J］. Journal of Turbomachinery， 2008， 130（3）： 031003. |
| 12 | FIQUET A L， AUBERT S， BRANDSTETTER C， et al. Acoustic resonance in an axial multistage compressor leading to non-synchronous blade vibration［J］. Journal of Turbomachinery， 2021， 143（9）： 091014. |
| 13 | LIU X H， WU Z H， SI C X， et al. Role of unsteady tip leakage flow in acoustic resonance inception of a multistage compressor［J］. Chinese Journal of Aeronautics， 2023， 36（4）： 165-181. |
| 14 | STAPELFELDT S， BRANDSTETTER C. Non-synchronous vibration in axial compressors： Lock-in mechanism and semi-analytical model［J］. Journal of Sound and Vibration， 2020， 488（prepublish）：115649. |
| 15 | 汪松柏， 陈勇， 吴亚东， 等. 轴流压气机转子叶片非同步振动研究进展［J］. 航空学报， 2023， 44（17）： 028044. |
| WANG S B， CHEN Y， WU Y D， et al. Research progress on non-synchronous vibration of axial compressor rotor blade［J］. Acta Aeronautica et Astronautica Sinica， 2023， 44（17）： 028044 （in Chinese）. | |
| 16 | FENG C C. The measurement of vortex induced effects in flow past stationary and oscillating circular and D-section cylinders［D］. Vancouver： University of British Columbia， 1968. |
| 17 | ZHANG W W， LI X T， YE Z Y， et al. Mechanism of frequency lock-in in vortex-induced vibrations at low Reynolds numbers［J］. Journal of Fluid Mechanics， 2015， 783： 72-102. |
| 18 | 李新涛. 钝体流致振动中若干复杂现象的诱发机理研究［D］. 西安： 西北工业大学， 2019. |
| LI X T. Study on the mechanism of several complex phenomena in flow-induced vibration of bluff bodies［D］.Xi’an： Northwestern Polytechnical University， 2019 （in Chinese）. | |
| 19 | 张伟伟， 豆子皓， 李新涛， 等. 桥梁若干流致振动与卡门涡街［J］. 空气动力学学报， 2020， 38（3）： 405-412. |
| ZHANG W W， DOU Z H， LI X T， et al. Various flow-induced vibrations of bridges and von Kármán vortex street［J］. Acta Aerodynamica Sinica， 2020， 38（3）： 405-412 （in Chinese）. | |
| 20 | WOODLEY B M， PEAKE N. Resonant acoustic frequencies of a tandem cascade. Part 1. Zero relative motion［J］. Journal of Fluid Mechanics， 1999， 393： 215-240. |
| 21 | 洪志亮， 赵国昌， 杨明绥， 等. 航空发动机压气机内部流体诱发声共振研究进展［J］. 航空学报， 2019， 40（11）： 023139. |
| HONG Z L， ZHAO G C， YANG M S， et al. Development of flow-induced acoustic resonance in aeroengine compressors［J］. Acta Aeronautica et Astronautica Sinica， 2019， 40（11）： 023139 （in Chinese）. | |
| 22 | HONG Z L， FU Y L， CHEN L F， et al. Experimental investigation on vortex sound interaction in self-induced acoustic resonance［J］. Journal of Sound Vibration， 2023， 548： 117510. |
| 23 | MOHANY A， ZIADA S. Measurements of the dynamic lift force acting on a circular cylinder in cross-flow and exposed to acoustic resonance［J］. Journal of Fluids and Structures， 2011， 27（8）： 1149-1164. |
| 24 | ALZIADEH M， MOHANY A. Applicability of the equivalent diameter approach to estimate vortex shedding frequency and acoustic resonance excitation from different finned cylinders in cross-flow［J］. Journal of Pressure Vessel Technology， 2022， 144（4）： 041406. |
| 25 | ALZIADEH M， MOHANY A. Vortex shedding characteristics and aerodynamic forces of a finned cylinder in cross-flow［J］. Physics of Fluids， 2022， 34（9）： 095110. |
| 26 | ALZIADEH M， MOHANY A. Vortex dynamics of tandem bare and spiral finned cylinders in cross-flow and their susceptibility to acoustic resonance excitation［J］. Physics of Fluids， 2022， 34（4）： 045105. |
| 27 | ALZIADEH M， MOHANY A. Flow structure and aerodynamic forces of finned cylinders during flow- induced acoustic resonance［J］. Journal of Fluids and Structures， 2023， 119： 103887. |
| 28 | HONG Z L， WANG X Y， JING X D， et al. Frequency lock-in mechanism in flow-induced acoustic resonance of a cylinder in a flow duct［J］. Journal of Fluid Mechanics， 2020， 884： A42. |
| 29 | HONG Z L， WANG X Y， JING X， et al. Vortex sound interaction in acoustic resonance of a flow duct containing a plate［J］. Journal of Sound and Vibration， 2020， 483： 115482. |
| 30 | MOHANY A， ZIADA S. Numerical simulation of the flow-sound interaction mechanisms of a single and two-tandem cylinders in cross-flow［J］. Journal of Pressure Vessel Technology， 2009， 131（3）： 031306. |
| 31 | GUESS A W. Calculation of perforated plate liner parameters from specified acoustic resistance and reactance［J］. Journal of Sound Vibration， 1975， 40（1）： 119-137. |
| 32 | PARKER R. Resonance effects in wake shedding from parallel plates： Some experimental observations［J］. Journal of Sound and Vibration， 1966， 4（1）： 62-72. |
| 33 | STOKES A N， WELSH M C. Flow-resonant sound interaction in a duct containing a plate， II： Square leading edge［J］. Journal of Sound Vibration， 1986， 104（1）： 55-73. |
| 34 | 付怡磊. 受限空间中涡声相互作用机理研究［D］. 天津： 中国民航大学， 2022. |
| FU Y L. Study on mechanism of vortex-acoustic interaction in confined space［D］.Tianjin： Civil Aviation University of China， 2022 （in Chinese）. | |
| 35 | WELSH M C， STOKES A N， PARKER R. Flow-resonant sound interaction in a duct containing a plate， part I： Semi-circular leading edge［J］. Journal of Sound Vibration， 1984， 95（3）： 305-323. |
/
| 〈 |
|
〉 |
CJA