基于非定常面元/黏性涡粒子混合法的旋翼/平尾非定常气动干扰
收稿日期: 2013-04-27
修回日期: 2013-06-27
网络出版日期: 2013-07-19
Rotor/Empennage Unsteady Aerodynamic Interaction with Unsteady Panel/Viscous Vortex Particle Hybrid Method
Received date: 2013-04-27
Revised date: 2013-06-27
Online published: 2013-07-19
旋翼/平尾非定常气动干扰是导致直升机纵向“抬头（Pitch-up）”现象的主要原因。为在直升机设计阶段准确分析旋翼/平尾非定常气动干扰以及由此引起的低速纵向操纵特性变化，通过涡量等效原则和Neumann物面边界条件建立了适用于旋翼/平尾气动干扰分析的非定常面元/黏性涡粒子混合法。该方法耦合了考虑尾迹时变效应的非定常面元法、黏性涡粒子法及涡量镜面法，以准确模拟旋翼和平尾的非定常气动载荷、旋翼尾迹的非定常特性以及旋翼尾迹对平尾的气动干扰效应。首先通过计算NASA ROBIN（Rotor Body Interaction）旋翼尾迹几何和诱导速度分布，并与实验测量值、时间精确自由尾迹及CFD计算结果对比验证方法的准确性。相比于时间精确自由尾迹，本文方法计算精度更高。随后分析了旋翼/平尾非定常气动干扰对平尾向下气动载荷和气动导数的影响，并分析了平尾构型对旋翼/平尾非定常气动干扰的影响规律。分析表明：旋翼尾迹与平尾干扰导致低速状态的平尾载荷突增，气动导数反号；低平尾气动载荷突增较大，高平尾较小，但高速气动导数反号；前置平尾载荷突增量减小，但对应速度范围较宽；右旋直升机右平尾载荷突增量较小，但气动导数特性基本不变。
谭剑锋 , 王浩文 , 吴超 , 林长亮 . 基于非定常面元/黏性涡粒子混合法的旋翼/平尾非定常气动干扰[J]. 航空学报, 2014 , 35(3) : 643 -656 . DOI: 10.7527/S1000-6893.2013.0324
The unsteady aerodynamic interaction of the rotor and empennage of a helicopter is the main cause of the "Pitch-up" phenomenon in helicopter flight dynamics. To accurately predict the rotor/empennage unsteady aerodynamic interaction and the variation of transverse handling characteristics caused by it under low-speed flight in the helicopter design phase, an unsteady panel/viscous vortex particle hybrid method is established through the equivalence of vorticity and Neumann boundary conditions. The unsteady aerodynamic loads of a rotor blade and empennage are described by the unsteady panel method while the rotor time-varying effect and the viscous and stretch effect of the rotor wake are represented by the viscous vortex particle method, and the interaction of the rotor wake and empennage is implemented through a vorticity mirror method. The rotor wake and induced velocity distribution of NASA ROBIN (Rotor Body Interaction) are predicted and compared with experiment, time-accurate free-wake and CFD results. It demonstrates that the present method is more accurate than the free-wake method. The effect of rotor wake/empennage unsteady aerodynamic interaction on empennage airloads is then analyzed, and the influence of empennage type on rotor wake/empennage aerodynamic interaction is also studied. It is shown that rotor wake/empennage aerodynamic interaction leads to an abrupt increase of empennage airloads and the reversal of aerodynamic derivatives in low-speed flight. The increase of low-set empennage's airload is relatively large, while that of high-set empennage is small, and the reversal of aerodynamic derivatives for high-set empennage occurs in high speed. Although the increasing of forward-set empennage airload is small, the range of speed is wide. Increase of the right-set empennage airload for right-handed rotor is small, but the derivative is similar to that of the left-set empennage.
[1] Leishman J G. Principles of helicopter aerodynamics[M]. 2nd ed. Cambridge: Cambridge University Press, 2006.
[2] Leoni R D. Black Hawk: the story of a world class helicopter[M]. Reston: AIAA, 2007.
[3] Cooper D E. YUH-60A stability and control[J]. Journal of the American Helicopter Society, 1978, 23(2): 9-18.
[4] Prouty R W, Amer K B. The YAH-64 empennage and tail rotor-a technical history[C]//Proceedings of the 38th American Helicopter Society Annual Forum, 1982: 247-261.
[5] Cassier A, Weneckers R, Pouradier J. Aerodynamic development of the Tiger helicopter[C]//Proceedings of the American Helicopter Society 50th Annual Forum, 1994: 244-252.
[6] Lee B S, Choi J H, Kwon O J. Numerical simulation of free-flight rockets air-launched from a helicopter[J]. Journal of Aircraft, 2011, 48(5): 1766-1775.
[7] Shi Y J, Zhao Q J, Fan F, et al. A new single-blade based hybrid CFD method for hovering and forward-flight rotor computation[J]. Chinese Journal of Aeronautics, 2011, 24(2): 127-135.
[8] Cao Y H, Yu Z Q, Su Y, et al. Combined free wake/CFD methodology for predicting transonic rotor flow in hove[J]. Chinese Journal of Aeronautics, 2002, 15(2): 65-71.
[9] Conlisk A T. Modern helicopter rotor aerodynamics[J]. Progress in Aerospace Science, 2001, 37(5): 419-475.
[10] Bhagwat M J. Mathematical modeling of the transient dynamics of helicopter rotor wakes using a time-accurate free-vortex method[D]. College Park: University of Maryland, 2001.
[11] Li C H, Xu G H. The rotor free-wake analytical method for tiltrotor aircraft in hover and forward flight[J]. Acta Aerodynamica Sinica, 2005, 23(2): 152-156. (in Chinese) 李春华, 徐国华. 悬停和前飞状态倾转旋翼机的旋翼自由尾迹计算方法[J]. 空气动力学学报, 2005, 23(2): 152-156.
[12] Tan J F, Wang H W, Lin C L. Analysis of rotor parameters on rotor hover performance by lifting-surface and free wake method[J]. Acta Aeronautica et Astronautica Sinica, 2012, 33(2): 249-257. (in Chinese) 谭剑锋, 王浩文, 林长亮. 基于升力面自由尾迹的直升机旋翼悬停性能参数影响研究[J]. 航空学报, 2012, 33(2): 249-257.
[13] Wang H W, Gao Z. Rotor vibratory load prediction based on generalized forces[J]. Chinese Journal of Aeronautics, 2004, 17(1): 28-33.
[14] Gangwani S T. Calculation of rotor wake induced empennage airloads[J]. Journal of the American Helicopter Society, 1983, 28(2): 37-46.
[15] Curtiss H C, Quackenbush T R. The influence of the rotor wake on rotorcraft stability and control[C]//15th European Rotorcraft Forum, 1989: 1-24.
[16] Gennaretti M, Bernardini G. Novel boundary integral formulation for blade-vortex interaction aerodynamics of helicopter rotors[J]. AIAA Journal, 2007, 45(6): 1169-1176.
[17] Tan J F, Wang H W. Panel/full-span free-wake coupled method for unsteady aerodynamics of helicopter rotor blade[J]. Chinese Journal of Aeronautics, 2013, 26(3): 535-543.
[18] Bhagwat M J, Leishman J G. Generalized viscous vortex model for application to free-vortex wake and aeroacoustic calculations[C]//The 58th Annual Forum and Technology Display of the AHS International, 2002: 11-13.
[19] Ploumhans P, Winckelmans G S. Vortex methods for high-resolution simulations of viscous flow past bluff bodies of general geometry[J]. Journal of Computational Physic, 2000, 165(2): 354-406.
[20] Ploumhans P, Winckelmans G S. Vortex methods for direct numerical simulation of three-dimensional bluff-body flows: applications to the sphere at [WTBX]Re[WTBZ]=300, 500, and 1000[J]. Journal of Computational Physics, 2002, 178(2): 427-463.
[21] He C J, Zhao J G. Modeling rotor wake dynamics with viscous vortex particle method[J]. AIAA Journal, 2009, 47(4): 902-915.
[22] Wei P, Shi Y J, Xu G H, et al. Nemerical method for simulating rotor flow field based upon viscous vortex model[J]. Acta Aeronautica et Astronautica Sinica, 2011, 33(5): 771-780. (in Chinese) 魏鹏, 史勇杰, 徐国华, 等. 基于黏性涡模型的旋翼流场数值方法研究[J]. 航空学报, 2011, 33(5): 771-780.
[23] Lindsay K, Krasny R. A particle method and adaptive treecode for vortex sheet motion in three-dimensional flow[J]. Journal of Computational Physics, 2001, 172(2): 879-907.
[24] Richason T F, Katz J. Unsteady panel method for flows with multiple bodies moving along various paths[J]. AIAA Journal, 1994, 32(1): 62-68.
[25] Hess J, Smith A M O. Calculation of non-lifting potential flow about arbitrary three-dimensional bodies[J]. Journal of Ship Research, 1964, 8(2): 22-44.
[26] Lorber P F, Egolf T A. An unsteady helicopter rotor-fuselage aerodynamic interaction anaylsis[J]. Journal of the American Helicopter Society, 1990, 35(3): 32-42.
[27] Winckelmans G S. Topics in vortex methods for the computation of three- and two-dimensional incompressible unsteady flows[D]. California: California Institute of Technology, 1989.
[28] Chorin A J. Numerical study of slightly viscous flow[J]. Journal of Fluid Mechanics, 1973, 57(4): 785-796.
[29] Fishelov D. A new vortex scheme for viscous flows[J]. Journal of Computational Physics, 1990, 86(1): 211-224.
[30] Degond P, Mas-Gallic S. The weighted particle method for convection-diffusion equations. Part 1. The case of an isotropic viscosity[J]. Mathematics of Computation, 1989, 53(188): 485-507.
[31] Cottet G H, Koumoutsakos P. Vortex methods theory and practice[M]. Cambridge: Cambridge University Press, 2000.
[32] Greengard L, Rokhlin V. A fast algorithm for particle simulations[J]. Journal of Computational Physics, 1997, 135(2): 280-292.
[33] Hess J L. Calculation of potential flow about arbitrary three-dimensional lifting bodies, final technical report, MDC J5679-01[R]. 1972.
[34] Ghee T A, Berry J D, Zori L A J, et al. Wake geometry measurements and analytical calculations on a small-scale rotor model, NASA-TP-3584[R]. Washington, D.C.: NASA, 1996.
[35] Arthur E P, Berry D B. Description of the U.S. Army small-scale 2-meter rotor test system, NASA-TM-87762[R]. Washington, D.C.: NASA, 1987.
[36] Elliott J, Althoff S, Sailey R. Inflow measurement made with a laser velocimeter on a helicopter model in forward flight, NASA-TM-100541[R]. Washington, D.C.: NASA, 1988.
[37] Ni X P. Manual of helicopter[M]. Beijing: Aviation Industry Press, 2003. (in Chinese) 倪先平. 直升机手册[M]. 北京: 航空工业出版社, 2003.
/
| 〈 |
|
〉 |
CJA