典型金属民机机身结构坠撞特性试验

doi:10.7527/S1000-6893.2022.26234

论文

本期目录 | 过刊浏览 | 高级检索

前一篇 | 后一篇

典型金属民机机身结构坠撞特性试验

张欣玥^1,2,3, 惠旭龙^1,2,3, 刘小川^1,2,3, 白春玉^1,2,3

1. 中国飞机强度研究所, 西安 710065;
2. 结构冲击动力学航空科技重点实验室, 西安 710065;
3. 陕西省飞行器振动冲击与噪声重点实验室, 西安 710065

收稿日期:2021-08-16 修回日期:2022-04-08 出版日期:2022-06-15 发布日期:2022-04-06
通讯作者: 刘小川,E-mail:asri02@163.com E-mail:asri02@163.com
基金资助:
民机专项科研项目（MJ-2017-F-15）

Experimental study on crash characteristics of typical metal civil aircraft fuselage structure

ZHANG Xinyue^1,2,3, XI Xulong^1,2,3, LIU Xiaochuan^1,2,3, BAI Chunyu^1,2,3

1. Aircraft Strength Research Institute of China, Xi'an 710065, China;
2. Aviation Key Laboratory of Science and Technology on Structures Impact Dynamics, Xi'an 710065, China;
3. Shaanxi Province Key Laboratory of Aircraft Vibration, Impact and Noise, Xi'an 710065, China

Received:2021-08-16 Revised:2022-04-08 Online:2022-06-15 Published:2022-04-06
Supported by:
Specialized Research Project of Civil Aircraft (MJ-2017-F-15)

摘要/Abstract

摘要： 为验证典型金属飞机机身结构的适坠性，开展了机身等直段结构在5.91 m/s下的垂直坠撞试验，得到了地面撞击载荷、机身结构变形及机身结构典型位置和假人的动态响应数据，分析了坠撞过程中机身结构的变形失效机理、载荷传递规律及能量吸收特性，提出了提高机身结构适坠性的设计方法。试验研究表明，在坠撞冲击载荷作用下，客舱地板横梁以下结构出现较为严重的变形，机身结构呈现非对称的破坏模式。在坠撞过程中，由于机身框和横梁变形吸收了大部分冲击能量，因此，相较于立柱处加速度峰值，传递至乘员处加速度峰值减小了90%左右。由综合适坠性评估指数可知，机身结构在5.91 m/s的坠撞速度下，具有良好的适坠性。

关键词: 民机, 适坠性, 坠撞试验, 加速度响应, 吸能

Abstract: To verify the crashworthiness of typical metal aircraft fuselage structure, this paper has carried out the fuselage straight segment structure vertical crash test under the velocity of 5.91 m/s. Ground impact load, fuselage deformation, acceleration response of typical positions at fuselage, and dummy response are obtained. The fuselage structure failure mechanism, the regularity of load transfer and the energy absorption characteristics during the crash are analyzed. The crashworthiness design methods of the fuselage are put forward. The experimental study shows that under the impact load the structure of the cabin floor under the beam appears serious deformation and damage, and the fuselage presents a non-symmetrical failure mode. During the impact,the fuselage structure absorbs most of the impact energy through the deformation and fracture of the columns,the deformation and fracture of the frames and the deformation of the beams. Therefore, compared with the peak acceleration at the column, the peak acceleration at the occupant decreases by about 90%. It can be known from the integrated crashworthiness index that the fuselage structure has good crashworthiness at the crash velocity of 5.91 m/s.

Key words: civil aircraft, crashworthiness, drop test, acceleration response, energy absorption

中图分类号:

V271.1

张欣玥, 惠旭龙, 刘小川, 白春玉. 典型金属民机机身结构坠撞特性试验[J]. 航空学报, 2022, 43(6): 526234-526234.

ZHANG Xinyue, XI Xulong, LIU Xiaochuan, BAI Chunyu. Experimental study on crash characteristics of typical metal civil aircraft fuselage structure[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2022, 43(6): 526234-526234.

参考文献

[1] LIU X C, GUO J, BAI C Y, et al. Drop test and crash simulation of a civil airplane fuselage section[J]. Chinese Journal of Aeronautics, 2015, 28(2):447-456.
[2] SIROMANI D. Crashworthy design and analysis of aircraft structures[D]. Philadelphia:Drexel University, 2013.
[3] 刘小川, 郭军, 孙侠生, 等. 民机机身段和舱内设施坠撞试验及结构适坠性评估[J]. 航空学报, 2013, 34(9):2130-2140. LIU X C, GUO J, SUN X S, et al. Drop test and structure crashworthiness evaluation of civil airplane fuselage section with cabin interiors[J]. Acta Aeronautica et Astronautica Sinica, 2013, 34(9):2130-2140(in Chinese).
[4] 刘小川, 白春玉, 惠旭龙, 等. 民机机身结构耐撞性研究的进展与挑战[J]. 固体力学学报, 2020, 41(4):293-323. LIU X C, BAI C Y, XI X L, et al. Progress and challenge of research on crashworthiness of civil airplane fuselage structures[J]. Chinese Journal of Solid Mechanics, 2020, 41(4):293-323(in Chinese).
[5] 刘小川, 周苏枫, 马君峰, 等. 民机客舱下部吸能结构分析与试验相关性研究[J]. 航空学报, 2012, 33(12):2202-2210. LIU X C, ZHOU S F, MA J F, et al. Correlation study of crash analysis and test of civil airplane sub-cabin energy absorption structure[J]. Acta Aeronautica et Astronautica Sinica, 2012, 33(12):2202-2210(in Chinese).
[6] GUIDA M, MARULO F, ABRATE S. Advances in crash dynamics for aircraft safety[J]. Progress in Aerospace Sciences, 2018, 98:106-123.
[7] MOSTAFA R. Virtual test & simulation[C]//Engineering, Operations & Technology, 2013:1-24.
[8] PERFETTO D, DE LUCA A, LAMANNA G, et al. Drop test simulation and validation of a full composite fuselage section of a regional aircraft[J]. Procedia Structural Integrity, 2018, 12:380-391.
[9] DI PALMA L, DI CAPRIO F, CHIARIELLO A, et al. Vertical drop test of composite fuselage section of a regional aircraft[J]. AIAA Journal, 2020, 58(1):474-487.
[10] HASHEMI S R, WALTON A C. A systematic approach to aircraft crashworthiness and impact surface material models[J]. Proceedings of the Institution of Mechanical Engineers, Part G:Journal of Aerospace Engineering, 2000, 214(5):265-280.
[11] WAIMER M, FESER T, SCHATROW P, et al. Crash concepts for CFRP transport aircraft-comparison of the traditional bend frame concept versus the developments in a tension absorbers concept[J]. International Journal of Crashworthiness, 2018, 23(2):193-218.
[12] FASANELLA E L, ALFARO-BOU E. Vertical drop test of a transport fuselage section located aft of the wing:NASA TM-89025[R]. Washington,D.C.:NASA, 1986.
[13] WILLIAMS M S, HAYDUK R J. Vertical drop test of a transport fuselage center section including the wheel wells:NASA TM-85706[R]. Washington,D.C.:NASA, 1983.
[14] FASANELL E L, JACKSON K E, JONES Y T, et al. Crash simulation of a Boeing 737 fuselage section vertical drop test[C]//Proceedings of the Third KRASH User's Conference, 2001.
[15] FASANELL E L, JACKSON K E. Crash simulation of a vertical drop test of a B737 fuselage section with auxiliary fuel tank:23681-0001[R]. U.S. Army Research Laboratory, Vehicle Technology Center, Langley Research Center, 2002.
[16] KAREN E J, EDWIN L F. Crash simulation of a vertical drop test of a B737 fuselage section with overhead bins and luggage[C]//Proceedings of the Third Triennial Aircraft Fire and Cabin Safety Conference, 2001:22-25.
[17] ABRAMOWITZ A, SMITH T G, VU T, et al. Vertical drop test of a narrow-body transport fuselage section with overhead stowage bins[R]. Warrendale:SAE International, 2002.
[18] JACKSON K E. Finite element simulations of two vertical drop tests of F-28 Fuselage sections:NASA/TM-2018-219807[R].Washington,D.C.:NASA, 2018.
[19] JACKSON K E, FASANELLA E L. Development of an LS-DYNA model of an ATR42-300 aircraft for crash simulation[C]//2003 SAE World Aviation Congress, 2003.
[20] KUMAKURA I, MINEGISHI M, IWASAKI K, et al. Summary of vertical drop tests of YS-11 transport fuselage sections[R].Warrendale:SAE International, 2003.
[21] KUMAKURA I, MINEGISHI M, IWASAKI K, et al. Vertical drop test of a transport fuselage section[R].Warrendale:SAE International, 2002.
[22] REN Y R, XIANG J W, MENG S H, et al. Crashworthiness of civil aircraft subject to soft soil and concrete impact surface[J]. Procedia Engineering, 2014, 80:193-201.
[23] 任毅如, 向锦武, 郑建强, 等. 典型民机机身段水上冲击数值模拟方法及其耐撞性研究[J]. 工程力学, 2016, 33(5):241-248. REN Y R, XIANG J W, ZHENG J Q, et al. Research on the numerical method and crashworthiness of typical civil aircraft fuselage for water impact[J]. Engineering Mechanics, 2016, 33(5):241-248(in Chinese).
[24] 冯振宇, 张晓敏, 牟浩蕾, 等. 不同冲击条件对机身结构适坠性的影响[J]. 机械科学与技术, 2013, 32(3):353-357. FENG Z Y, ZHANG X M, MOU H L, et al. Influences of different impact conditions on aircraft fuselage crashworthiness[J]. Mechanical Science and Technology for Aerospace Engineering, 2013, 32(3):353-357(in Chinese).
[25] 彭亮. 基于乘员生存性的机身结构适坠性设计与评价方法研究[D]. 西安:西北工业大学, 2018. PENG L. Research on design and evaluation method of airframe structural crashworthiness based on occupants survivability[D]. Xi'an:Northwestern Polytechnical University, 2018(in Chinese).
[26] 中国民用航空规章:第25部-运输类飞机适航标准:CCAR-25[S]. 北京:中国民用航空局, 2011. China Civil Aviation Regulation:25-airworthiness standard of transport aircraft:CCAR-25[S]. Beijing:Civil Aviation Administration of China, 2011(in Chinese).
[27] 白春玉, 刘小川, 惠旭龙, 等. 民机适坠性研究中的垂向坠撞速度问题探讨[J]. 航空科学技术, 2020, 31(9):11-17. BAI C Y, LIU X C, XI X L, et al. Discussion on the problem of vertical crash velocity in the study of the crashworthiness of civil aircraft[J]. Aeronautical Science & Technology, 2020, 31(9):11-17(in Chinese).
[28] Society of Automotive Engineers. Recommended practice:Instrumentation for impact test-Part 1, Electronic instrumentation:SAE J211/1[S]. Warrendale:SAE International,2007.

E-mail：hkxb@buaa.edu.cn

关于我们

期刊社服务

专业学科

封面文章

友情链接

主管单位：中国科学技术协会主办单位：中国航空学会北京航空航天大学

典型金属民机机身结构坠撞特性试验

Experimental study on crash characteristics of typical metal civil aircraft fuselage structure

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王迪, 冷岩, 杨龙, 韩忠华, 钱战森. 基于广义Burgers方程的声爆传播特性大气湍流影响[J]. 航空学报, 2023, 44(2): 626318-626318.
[2]	丁玉临, 韩忠华, 乔建领, 聂晗, 宋文萍, 宋笔锋. 超声速民机总体气动布局设计关键技术研究进展[J]. 航空学报, 2023, 44(2): 626310-626310.
[3]	乔建领, 韩忠华, 丁玉临, 宋文萍, 宋笔锋. 分层大气湍流场对远场声爆传播的影响[J]. 航空学报, 2023, 44(2): 626350-626350.
[4]	岑飞, 刘志涛, 蒋永, 郭天豪, 张磊, 孔轶男. 民机极限飞行状态非定常气动力建模[J]. 航空学报, 2022, 43(8): 125582-125582.
[5]	王育鹏, 田文朋, 宋鹏飞, 夏峰, 冯建民. 民机全机疲劳试验综合加速技术研究与验证[J]. 航空学报, 2022, 43(5): 224919-224919.
[6]	冯振宇, 迟琪琳, 崔怀天, 解江, 牟浩蕾. 平纹机织与2.5D机织复合材料平板弹道冲击特性对比[J]. 航空学报, 2022, 43(5): 425116-425116.
[7]	王佳铭, 李志刚, 梁方正, 刘婉婷, 廖就, 陈芳育, 李萌, 邵特立. 面向直升机抗坠毁的新型夹心八边形蜂窝设计、仿真和理论研究[J]. 航空学报, 2022, 43(5): 225244-225244.
[8]	张力文, 宋文萍, 韩忠华, 钱战森, 宋笔锋. 声爆产生、传播和抑制机理研究进展[J]. 航空学报, 2022, 43(12): 25649-025649.
[9]	袁吉森, 孙爵, 李玲玉, 于晟浩, 聂晗, 高亮杰, 韩忠华, 钱战森. 超声速飞机层流布局设计与评估技术进展[J]. 航空学报, 2022, 43(11): 526316-526316.
[10]	聂晗, 宋文萍, 韩忠华, 陈坚强, 段茂昌, 万兵兵. 面向超声速民机层流机翼设计的转捩预测方法[J]. 航空学报, 2022, 43(11): 526342-526342.
[11]	王迪, 钱战森, 冷岩. 广义Burgers方程声爆传播模型高阶格式离散[J]. 航空学报, 2022, 43(1): 124916-124916.
[12]	董磊, 向晨阳, 赵长啸, 党香俊, 史春蕾. 民机驾驶舱显示触控系统人机工效综合评价[J]. 航空学报, 2021, 42(6): 624053-624053.
[13]	鲁志东, 张曙光, 戴闰志, 黄铭媛. 大型民机进近着陆段异常能量风险判据研究[J]. 航空学报, 2021, 42(6): 624132-624132.
[14]	岑飞, 李清, 刘志涛, 蒋永, 张磊. 民机极限飞行状态的动态气动力试验与建模[J]. 航空学报, 2020, 41(8): 123664-123664.
[15]	贾宝惠, 邓婉怡, 王毅强. 三层三级民机修理级别经济性分析模型的改进[J]. 航空学报, 2020, 41(3): 323468-323468.