单个压电风扇传热特性

doi:10.7527/S1000-6893.2017.120982

流体力学与飞行力学

本期目录 | 过刊浏览 | 高级检索

前一篇 | 后一篇

单个压电风扇传热特性

李鑫郡, 张靖周, 谭晓茗

南京航空航天大学能源与动力学院, 南京 210016

收稿日期:2016-11-24 修回日期:2017-02-09 出版日期:2017-07-15 发布日期:2017-03-20
通讯作者: 张靖周,E-mail:zhangjz@nuaa.edu.cn E-mail:zhangjz@nuaa.edu.cn
基金资助:
国家自然科学基金（51106073）；中央高校基本科研业务费专项资金（NS2014018）

Characteristics of heat transfer with single piezoelectric fan

LI Xinjun, ZHANG Jingzhou, TAN Xiaoming

College of Energy and Power Engineering, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China

Received:2016-11-24 Revised:2017-02-09 Online:2017-07-15 Published:2017-03-20
Supported by:
National Natural Science Foundation of China (51106073);the Fundamental Research Funds for the Central Universities (NS2014018)

摘要/Abstract

摘要：

基于压电风扇运动规律的激光多普勒测振仪测试结果，利用动网格技术对单个垂直壁面压电风扇的三维非定常流动和传热特性进行了数值模拟，同时应用红外热像仪对表面局部对流换热系数分布进行了测量。研究结果表明：时均对流换热系数的数值模拟与实验结果具有良好的一致性；加热表面的存在，导致压电风扇激励的涡系结构与其在自由空间振动时诱导的流场存在一定的差异，脱落涡相比于自由空间时更易于破碎；压电风扇振动诱导的涡冲击加热表面所形成的近壁流动呈现出明显的平行于风扇的侧向流动，而在压电风扇两侧边则出现卷吸的特点，叶尖包络区对应的壁面局部对流换热有显著的强化作用，表面对流换热系数分布在包络区外围呈现出明显的哑铃状特征。

关键词: 压电风扇, 对流换热, 数值模拟, 振动测试, 换热系数

Abstract:

A numerical simulation of the three-dimensional unsteady flow and heat transfer characteristics of a single piezoelectric fan arranged normally to the heated surface is performed using dynamic meshing scheme. The displacement of the vibrating fan is determined from the vibration test by using the laser doppler vibrameter. An experimental test for the distribution of the local convective heat transfer coefficient is also made using the infrared camera. The distribution of the cycle-averaged local heat transfer coefficient obtained by the numerical simulation is found to be in good consistence with the test result. Due to the existence of the heated surface, the vortical structures excited by the piezoelectric fan behave somewhat differently from those observed in the free space. The shedding vortex is easier to be broken down in relation to the case in the free space. The near-wall flow field induced by the piezoelectric fan demonstrates obvious lateral flow parallel to the fan, and suction flow on both sides of the fan. The local convective heat transfer in the fan-tip vibration envelope is effectively enhanced. Dumbbell-shaped distribution of local convective heat transfer around the fan-tip vibration envelope is demonstrated.

Key words: piezoelectric fan, convective heat transfer, numerical simulation, vibration test, heat transfer coefficient

中图分类号:

O354
V231.11

李鑫郡, 张靖周, 谭晓茗. 单个压电风扇传热特性[J]. 航空学报, 2017, 38(7): 120982-120982.

LI Xinjun, ZHANG Jingzhou, TAN Xiaoming. Characteristics of heat transfer with single piezoelectric fan[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2017, 38(7): 120982-120982.

参考文献

[1] YOO J H, HONG J I, CAO W. Piezoelectric ceramic bimorph coupled to thin metal plate as cooling fan for electronic devices[J]. Sensors Actuators A, 2000, 79(1): 8-12.
[2] WU T, RO P I, KINGON A I, et al. Piezoelectric resonating structures for microelectronic cooling[J]. Smart Materials and Structures, 2003, 12(2): 181-187.
[3] GILSON G M, PICKERING S J, HANN D B, et al. Piezoelectric fan cooling: A novel high reliability electric machine thermal management solution[J]. IEEE Transactions on Industrial Electronics, 2013, 60(11): 4841-4851.
[4] TODA M. Theory of air flow generation by a resonant type PVF2 bimorph cantilever vibrator[J]. Ferroelectrics, 1979, 22(3): 911-918.
[5] SYDNEY M W, BASAK S, GARIMELLA S V, et al. Piezoelectric fans using higher flexural models for electronics cooling applications[J]. IEEE Transactions on Components and Packaging Technologies, 2007, 30(1): 119-128.
[6] KIM Y H, WERELEY S T, CHUN C H. Phase-resolved flow field produced by a vibrating cantilever plate between two endplates[J]. Physics in Fluids, 2004, 16(1): 145-162.
[7] KIM Y H, CHUN C H, WERELEY S. Flow field around a vibrating cantilever: Coherent structure education by continuous wavelet transform and proper orthogonal decomposition[J]. Journal of Fluid Mechanics, 2011, 669: 584-606.
[8] CHOI M, CIERPKA C, KIM Y H. Vortex formation by a vibrating cantilever[J]. Journal of Fluids and Structures, 2012, 31: 67-78.
[9] ACIKLAIN T, WAIT S M, GARIMELLA S V. Experimental investigation of the thermal performance of piezoelectric fans[J]. Heat Transfer Engineering, 2004, 25(1): 4-14.
[10] KIMBER M, GARIMELLA S V, RAMAN A. Local heat transfer coefficients induced by piezoelectrically actuated vibrating cantilevers[J]. ASME Journal of Heat Transfer, 2007, 129(9): 1168-1176.
[11] KIMBER M, GARIMELLA S V. Measurement and prediction of the cooling characteristics of a generalized vibrating piezoelectric fan[J]. International Journal of Heat and Mass Transfer, 2009, 52(19-20): 4470-4478.
[12] KIMBER M, GARIMELLA S V. Cooling performance of arrays of vibrating cantilevers[J]. ASME Journal of Heat Transfer, 2009, 131(11): 111401-1-8.
[13] LIU S F, HUANG R T, SHEU W J, et al. Heat transfer by a piezoelectric fan on a flat surface subject to the influence of horizontal/vertical arrangement[J]. International Journal of Heat and Mass Transfer, 2009, 52(11-12): 2565-2570.
[14] FAIRUZ Z M, SUFIAN S F, ABDULLAH M Z, et al. Effect of piezoelectric fan mode shape on the heat transfer characteristics[J]. International Communications in Heat and Mass Transfer, 2014, 52: 140-151.
[15] 谭蕾, 谭晓茗, 张靖周. 压电风扇激励非定常流动和换热特性数值研究[J]. 航空学报, 2013, 34(6): 1277-1284. TAN L, TAN X M, ZHANG J Z. Numerical investigation on unsteady flow and heat transfer characteristics of piezoelectric fan[J]. Acta Aeronautica et Astronautica Sinica, 2013, 34(6): 1277-1284 (in Chinese).
[16] TAN L, ZHANG J Z, TAN X M. Numerical investigation of convective heat transfer on a vertical surface due to resonating cantilever beam[J]. International Journal of Thermal Sciences, 2014, 80: 93-107.
[17] 孔岳, 李敏, 吴蒙蒙. 压电风扇非定常流场速度分布的数值研究[J]. 工程力学, 2016, 33(1): 209-216. KONG Y, LI M, WU M M. Numerical investigation on the velocity of unsteady flow field induced by piezoelectric fan[J]. Engineering Mechanics, 2016, 33(1): 209-216 (in Chinese).
[18] BREVET P, DEJEU C, DORIGNAC E, et al. Heat transfer to a row of impinging jets in consideration of optimization[J]. International Journal of Heat and Mass Transfer, 2002, 45(20): 4191-4200.
[19] MOFFAT R J. Describing the uncertainties in experimental results[J]. Experimental Thermal and Fluid Science, 1998, 1(1): 3-17.
[20] LIN C N. Enhanced heat transfer performance of cylindrical surface by piezoelectric fan under forced convection conditions[J]. International Journal of Heat and Mass Transfer, 2013, 60: 296-308.
[21] JEONG J, HUSSAIN F. On the definition of a vortex[J]. Journal of Fluid Mechanics, 1995, 285(1): 69-94.

E-mail：hkxb@buaa.edu.cn

关于我们

期刊社服务

专业学科

封面文章

友情链接

主管单位：中国科学技术协会主办单位：中国航空学会北京航空航天大学

单个压电风扇传热特性

Characteristics of heat transfer with single piezoelectric fan

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	郑梅, 冯丽娟, 秦娜, 尹金鸽. 短舱防冰系统三维内外流耦合计算方法[J]. 航空学报, 2023, 44(1): 627425-627425.
[2]	夏侯唐凡, 陈江涛, 邵志栋, 吴晓军, 刘宇. 随机和认知不确定性框架下的CFD模型确认度量综述[J]. 航空学报, 2022, 43(8): 25716-025716.
[3]	杨建凯, 顾冬冬, 葛庆, 檀晨晨, 文雨. 铝合金激光增材制造支撑布局及精确成形机制[J]. 航空学报, 2022, 43(4): 525331-525331.
[4]	姜有旭, 李杰, 杨钊. 某层流机翼验证机风洞试验数据修正方法[J]. 航空学报, 2022, 43(11): 526814-526814.
[5]	段俊亦, 童福林, 李新亮, 刘洪伟. 压缩-膨胀湍流边界层平均摩阻分解[J]. 航空学报, 2022, 43(1): 625915-625915.
[6]	刘朋欣, 袁先旭, 孙东, 傅亚陆, 李辰. 高温化学非平衡湍流边界层直接数值模拟[J]. 航空学报, 2022, 43(1): 124877-124877.
[7]	沈鹏飞, 刘朋欣, 孙东, 袁先旭. 马赫6柱-裙构型激波/湍流边界层干扰摩阻统计特性[J]. 航空学报, 2022, 43(1): 626005-626005.
[8]	刘朋欣, 袁先旭, 梁飞, 李辰, 孙东. 高温化学非平衡湍流边界层脉动量象限分析[J]. 航空学报, 2021, 42(S1): 726338-726338.
[9]	鲍俊, 王瑜, 牛潜, 朱锡冬, 程建杰. 喷雾液滴撞击液膜影响参数及流动机理分析[J]. 航空学报, 2021, 42(S1): 726360-726360.
[10]	陈崇沛, 梁剑寒, 关清帝, 高天运. 守恒型可压缩一维湍流方法及其在超声速标量混合层中的应用[J]. 航空学报, 2021, 42(S1): 726364-726364.
[11]	李青, 涂国华, 余钊圣, 林昭武, 李婷婷, 袁先旭. 惯性颗粒在非均匀加速流中的输运问题[J]. 航空学报, 2021, 42(S1): 726390-726390.
[12]	吕元伟, 张靖周, 单勇, 孙文静. 冠齿喷管射流冲击半圆形靶面的对流换热[J]. 航空学报, 2021, 42(7): 124762-124762.
[13]	李成成, 李芳, 杨斌, 王莹. 等离子体激励抑制喷管分离流动数值模拟[J]. 航空学报, 2021, 42(7): 124547-124547.
[14]	刘宗兴, 刘军, 李维娜. 爆炸冲击载荷下典型机身结构动响应及破坏[J]. 航空学报, 2021, 42(2): 224252-224252.
[15]	张云光, 李志强, 王耀奇, 李红, 李淑慧. 2060铝锂合金冷模热成形界面换热系数确定的实验与算法[J]. 航空学报, 2021, 42(2): 423805-423805.