考虑遮蔽区影响的旋翼三维水滴撞击特性计算新方法

doi:10.7527/S1000-6893.2016.0313

流体力学与飞行力学

本期目录 | 过刊浏览 | 高级检索

前一篇 | 后一篇

考虑遮蔽区影响的旋翼三维水滴撞击特性计算新方法

陈希, 招启军

南京航空航天大学直升机旋翼动力学国家级重点实验室, 南京 210016

收稿日期:2016-09-01 修回日期:2016-11-25 出版日期:2017-06-15 发布日期:2016-12-05
通讯作者: 招启军,E-mail:zhaoqijun@nuaa.edu.cn E-mail:zhaoqijun@nuaa.edu.cn
基金资助:
国家自然科学基金（11272150）

New method for predicting 3-D water droplet impingement on rotor considering influence of shadow zone

CHEN Xi, ZHAO Qijun

National Key Laboratory of Science and Technology on Rotorcraft Aeromechanics, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China

Received:2016-09-01 Revised:2016-11-25 Online:2017-06-15 Published:2016-12-05
Supported by:
National Natural Science Foundation of China (11272150)

摘要/Abstract

摘要：

针对直升机旋翼三维黏性流场特有的复杂环境，建立了一种基于欧拉法的旋翼三维水滴撞击特性计算的新方法。首先，在旋翼桨叶嵌套网格的基础上，发展了一套用于预测旋翼绕流流场的计算流体力学（CFD）模拟方法。然后，为克服传统直升机旋翼二维水滴撞击特性计算方法的不足，充分考虑旋翼流场的三维效应，在嵌套网格中基于欧拉法求解旋翼三维水滴撞击流场。其中，为解决尾流等区域的密度脉冲现象所引起的稳定性和收敛性问题，提出并建立了遮蔽区扩散模型。该模型通过判断遮蔽区变量，在计算域中动态生成遮蔽区域，并随迭代步数逐渐扩散。最后，通过与NACA0012翼型及国外UH-1H桨叶的试验和计算结果的对比，验证了旋翼三维水滴撞击特性计算新方法的可靠性，并进行了温度和水滴当量直径（MVD）对旋翼三维水滴撞击特性的影响分析。结果表明：遮蔽区扩散模型的加入，使二维情况的计算时间减少了22%，并增加了三维情况的计算稳定性，显著提高了旋翼三维水滴撞击特性的计算效率；沿着旋翼桨叶展向位置增大的方向，旋翼桨叶剖面水滴撞击范围有所增大，最大水滴局部收集系数呈先增加后减少再增加的变化趋势，其变化幅度接近50%；旋翼桨叶表面的水滴撞击区域和水滴局部收集系数随水滴当量直径的增加而增加。

关键词: 旋翼, 结冰, 水滴撞击特性, 欧拉法, 遮蔽区, 计算流体力学

Abstract:

For the complex 3-D viscous flowfield of the helicopter rotor, a new 3-D Eulerian method is established for calculating the droplet impingement on the rotor. The Computional Fluid Dynamics (CFD) simulation method for predicting the rotor flowfield is developed based on the embedded grid method. Considering the 3-D effect of the rotor fully, the 3-D flowfield of droplets on the same embedded grids is solved by the Eulerian method to overcome the defects of the traditional 2-D calculation method. To overcome the problem of numerical stability and convergence by the density impulse in the wake area, a shadow zone dispersion model is proposed. In the model, a shadow variable is used to control the generation and dispersion of the shadow cells. The new Eulerian method is validated by comparing the calculation and experiment results of NACA0012 airfoil and UH-1H rotor in hover. In addition, the effects of the atmospheric temperature and Median Volumetric Diameter (MVD) of the droplet on the droplet impingement on the rotor are calculated and analyzed. Results show that the computation time of the 2-D droplet impingement property is reduced by 22% and the calculation stability of 3-D droplet impingement property is improved by using the shadow zone dispersion model. The droplet impingement area increases with the spanwise distance on the rotor blade. The maximum droplet local collection efficiency presents the change tendency of ‘increase-decrease-increase’, and the variation amplitude is close to 50%. The droplet impingement area and the collection efficiency increase with the increase of the MVD.

Key words: rotor, ice accretion, water droplet impingement property, Eulerian method, shadow zone, CFD

中图分类号:

V211.3

陈希, 招启军. 考虑遮蔽区影响的旋翼三维水滴撞击特性计算新方法[J]. 航空学报, 2017, 38(6): 120745-120745.

CHEN Xi, ZHAO Qijun. New method for predicting 3-D water droplet impingement on rotor considering influence of shadow zone[J]. ACTA AERONAUTICAET ASTRONAUTICA SINICA, 2017, 38(6): 120745-120745.

参考文献

[1] FLEMMING R J. The past twenty years of icing research and development at Sikorsky aircraft: AIAA-2002-0238[R]. Reston: AIAA, 2002.
[2] FLEMMING R J, ALLDRIDGE P, DOEPPNER R. Artificial icing tests of the S-92 helicopter in the McKinley Climatic Laboratory: AIAA-2004-0737[R]. Reston: AIAA, 2004.
[3] BRITTON R K, BOND T H, FLEMMING R J. An overview of a model rotor icing test in the NASA Lewis icing research tunnel: AIAA-1994-0716[R]. Reston: AIAA, 1994.
[4] WRIGHT W B, POTAPCZUK M G, LEVINSON L H. Comparison of LEWICE and GlennICE in the SLD regime: AIAA-2008-0439[R]. Reston: AIAA, 2008.
[5] IULIANO E, BRANDI V, MINGIONE G, et al. Water impingement prediction on multi-element airfoils by means of Eulerian and Lagrangian approach with viscous and inviscid air flow: AIAA-2006-1270[R]. Reston: AIAA, 2006.
[6] 胡剑平, 刘振侠, 张丽芬. 发动机整流支板大尺寸过冷水滴撞击特性[J]. 航空学报, 2011, 32(10): 1778-1785. HU J P, LIU Z X, ZHANG L F.Supercooled large droplet impact behaviors on an aero-engine strut[J]. Acta Aeronautica et Astronautica Sinica, 2011, 32(10): 1778-1785 (in Chinese).
[7] 易贤, 王开春, 桂业伟, 等. 结冰面水滴收集率欧拉计算方法研究及应用[J]. 空气动力学学报, 2010, 28(5): 596-601. YI X, WANG K C, GUI Y W, et al. Study on Eulerian method for icing collection efficiency computation and its application[J]. Acta Aerodynamica Sinica, 2010, 28(5): 596-601 (in Chinese).
[8] KIM J W, DENNIS P G, SANKAR L N, et al. Ice accretion modeling using an Eulerian approach for droplet impingement: AIAA-2013-0246[R]. Reston: AIAA, 2013.
[9] KINZEL M P, SAROFEEN C M, NOACK R W, et al. A finite-volume approach to modeling ice accretion: AIAA-2010-4230[R]. Reston: AIAA, 2010.
[10] BAIN J, SANKAR L N,GARZA D. A methodology for the prediction of rotor blade ice formation and shedding[C]//Proceedings of the SAE 2011 Aircraft and Engine icing and Ground Testing Conference. Warrendale, PA: SAE International, 2011.
[11] NARDUCCI R, KREEGER R E.Analysis of a hovering rotor in icing conditions: NASA/TM-2012-217126[R]. Washington, D.C.: NASA, 2012.
[12] CAO Y H, LI G Z, ZHONG G. Tandem helicopter trim and flight characteristics in the icing condition[J]. Journal of Aircraft, 2010, 47(5): 1559-1569.
[13] RAJMOHAN N, BAIN J, NUCCI M, et al. Icing studies for the UH-60A rotor in forward flight[C]//AHS Aeromechanics Specialists' Conference. Fairfax, VA: American Helicopter Society International, 2010.
[14] 张威, 林永峰, 陈平剑. 基于欧拉方法的旋翼翼型结冰数值模拟及参数影响[J]. 南京航空航天大学学报, 2011, 43(3): 375-380. ZHANG W, LIN Y F, CHEN P J. Numerical simulation of ice accretion and parameter effects based on Eulerian droplet model[J]. Journal of Nanjing University of Aeronautics & Astronautics, 2011, 43(3): 375-380 (in Chinese).
[15] BOURGAULT Y, HABASHI W G, DOMPIERRE J, et al. A Eulerian approach to supercooled droplets impingement calculations: AIAA-1997-0176[R]. Reston: AIAA, 1997.
[16] TONG X L, LUKE E A. Eulerian simulations of icing collection efficiency using a singularity diffusion model: AIAA-2005-1246[R]. Reston: AIAA, 2005.
[17] 杨胜华, 林贵平, 申晓斌. 三维复杂表面水滴撞击特性计算[J]. 航空动力学报, 2010, 25(2): 284-290. YANG S H, LIN G P, SHEN X B. Water droplet impingement prediction for three-dimensional complex surfaces[J]. Journal of Aerospace Power, 2010, 25(2): 284-290 (in Chinese).
[18] JUNG K Y, JUNG S K, MYONG R S, et al. A three-dimensional unstructured finite volume method for droplet impingement in aircraft icing: AIAA-2013-2576[R]. Reston: AIAA, 2013.
[19] LEE J D, HARDING R, PALKO R L. Documentation of ice shapes on the main rotor of a UH-1H helicopter in hover: NASA-CR-168332[R]. Washington, D.C.: NASA, 1984.
[20] 招启军, 徐国华. 新型桨尖旋翼悬停气动性能试验及数值研究[J]. 航空学报, 2009, 30(3): 422-429. ZHAO Q J, XU G H. Aerodynamic performance of rotor with new type blade-tip in hover based upon test and numerical investigations[J]. Acta Aeronautica et Astronautica Sinica, 2009, 30(3): 422-429 (in Chinese).
[21] CAO Y H, MA C, ZHANG Q, et al. Numerical simulation of ice accretions on an aircraft wing[J]. Aerospace Science and Technology, 2012, 23(1): 296-304.
[22] 陈希, 招启军, 赵国庆. 计入离心力影响的直升机旋翼翼型结冰数值模拟[J]. 航空动力学报, 2014, 29(9): 2158-2165. CHEN X, ZHAO Q J, ZHAO G Q. Numerical simulation for ice accretion on rotor airfoil of helicopter considering the effects of centrifugal force[J]. Journal of Aerospace Power, 2014, 29(9): 2158-2165 (in Chinese).

E-mail：hkxb@buaa.edu.cn

关于我们

期刊社服务

专业学科

封面文章

友情链接

主管单位：中国科学技术协会主办单位：中国航空学会北京航空航天大学

考虑遮蔽区影响的旋翼三维水滴撞击特性计算新方法

New method for predicting 3-D water droplet impingement on rotor considering influence of shadow zone

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	乔建领, 韩忠华, 丁玉临, 宋文萍, 宋笔锋. 分层大气湍流场对远场声爆传播的影响[J]. 航空学报, 2023, 44(2): 626350-626350.
[2]	陈勇, 孔维梁, 刘洪. 飞机过冷大水滴结冰气象条件运行设计挑战[J]. 航空学报, 2023, 44(1): 626973-626973.
[3]	黄雄, 曲仕茹, 张恒, 陈显调. 大型客机增升构型缝翼除冰状态失速特性[J]. 航空学报, 2023, 44(1): 627077-627077.
[4]	张恒, 李杰, 赵宾宾. 结冰翼型前缘下垂变弯度容冰特性改善机制[J]. 航空学报, 2023, 44(1): 627114-627114.
[5]	束珺, 徐东光, 韩志熔, 李斯, 黄雄. 结冰风洞过冷大水滴试验中混合翼设计[J]. 航空学报, 2023, 44(1): 627182-627182.
[6]	赵宾宾, 张恒, 李杰. 翼型结冰状态复杂分离流动数值模拟综述[J]. 航空学报, 2023, 44(1): 627211-627211.
[7]	马乙楗, 柴得林, 王强, 易贤, 孔满昭. 翼面结冰过程中的冰晶运动相变与黏附特性[J]. 航空学报, 2023, 44(1): 627817-627817.
[8]	牛俊杰, 桑为民, 李栋, 郝莲, 王泽林. 一种基于水滴收集量代理模型的结冰试飞空域确定方法[J]. 航空学报, 2023, 44(1): 627697-627697.
[9]	郭琪磊, 桑为民, 牛俊杰, 袁烨. 复杂气象条件下考虑结冰风险的无人机飞行策略[J]. 航空学报, 2023, 44(1): 627518-627518.
[10]	杨明月, 寿莹鑫, 唐勇, 刘畅, 许斌. 多四旋翼无人机编队保持与避碰控制[J]. 航空学报, 2022, 43(S1): 726913-726913.
[11]	孙杨, 昌敏, 白俊强. 微小型四旋翼无人机垂面栖停轨迹规划与控制[J]. 航空学报, 2022, 43(9): 325756-325756.
[12]	许文纲, 王志颖, 孙闯, 严如强, 陈雪峰. 转频调制下齿轮泵压力脉动机理[J]. 航空学报, 2022, 43(9): 625508-625508.
[13]	夏侯唐凡, 陈江涛, 邵志栋, 吴晓军, 刘宇. 随机和认知不确定性框架下的CFD模型确认度量综述[J]. 航空学报, 2022, 43(8): 25716-025716.
[14]	罗佳杰, 宋文滨. 层流机翼及其增升装置嵌套协同优化方法[J]. 航空学报, 2022, 43(8): 125377-125377.
[15]	谭剑锋, 何龙, 于领军, 周国臣. 基于黏性涡粒子/沙粒DEM的直升机沙盲建模[J]. 航空学报, 2022, 43(8): 125536-125536.